Blueprint CGLP-2 Manual de usuario

Blueprint®Controllers put the power of automation to work in garden environments everywhere. For safety and optimal performance,

please carefully read this document in full before installing and operating this Blueprint®CO2Generator.

rev:92014

Features

• Two,four,eightortenpreinstalledliquidpropaneornaturalgasburners

• Electronicignitionprovidesreliablestarts

• Dualsolenoidvalveseliminateopenpilotame

• Includesgasregulator,12’hoseandhanginghardware

• Built-insafetytip-overswitch

• Three-yearwarranty

Liquidpropanehose

with regulator

Natural gas hose

with regulator

24-VDCpowersupply Hardware

Speciﬁcations

LiquidPropane(LP)

Max. Area

Size(CuFt)

Max.CO2

(CuFt/Hr) BTU Rating VariableOutput Gas Pressure Power

Requirements Dimensions

CGLP-2 2,000 5.3 2,263-4,526 1-2burners

11” WC/2.8 kPa 400mA@24-VDC

9” x 10” x 18”

CGLP-4 4,000 10.6 2,263-9,052 1-4burners 15” x 8.5” x 18”

CGLP-4H 4,000 8.4 1,788-7,152 1-4burners 15” x 8.5” x 18”

CGLP-8 8,000 21.2 2,263-18,104 1-8burners 15” x 9.8” x 18”

CGLP-8H 8,000 16.7 1,788-14,304 1-8burners 15” x 9.8” x 18”

CGLP-10 10,000 26.5 2,263-22,630 1-10burners 15” x 9.8” x 18”

NaturalGas(NG)

Max. Area

Size(CuFt)

Max.CO2

(CuFt/Hr) BTU Rating VariableOutput Gas Pressure Power

Requirements Dimensions

CGNG-2 2,000 5.4 2,767-5,534 1-2burners

4.5” WC/1.15 kPa 400mA@24-VDC

9” x 10” x 18”

CGNG-4 4,000 10.8 2,767-11,068 1-4burners 15” x 8.5” x 18”

CGNG-4H 4,000 9.6 2,455-9,820 1-4burners 15” x 8.5” x 18”

CGNG-8 8,000 21.6 2,767-22,136 1-8burners 15” x 9.8” x 18”

CGNG-8H 8,000 19.2 2,455-19,640 1-8burners 15” x 9.8” x 18”

CGNG-10 10,000 27.7 2,767-27,670 1-10burners 15” x 9.8” x 18”

•Failuretoreadandunderstandtheseinstructionsbeforeinstallingoroperatingthisproductcouldresultin

 personalinjuryorpropertydamage.

•Installationandconnectionofgaslinesmustbecompletedincompliancewithlocalandnationalregulations.

•Donotstoregasolineorotherammablegasesorliquidsneartheunit.

•KeepobjectsawayfromtheGeneratorastheelectrodesproducesparks.

•InstalltheGeneratorinanadequatelyventilatedarea.Withoutadequateventilation,CO2canreachtoxiclevels. 

 Levelsabove2500ppmcancauseheadachesandothersymptoms,andlevelsabove5000ppmaretoxic.

•DonotusethestandardGeneratorataltitudeshigherthan4,500ftabovesealeveliftheburnersareproducing

 yellowame.

•TheGeneratorisdesignedtobeoperatedonlywhilehanging.DonotoperatetheGeneratoronatableorother 

 surfacebecausetheunitrequiresunrestrictedairowthroughthebottomoftheunit.

•DonotturnontheGeneratorwithoutreadingthe“Start-upProcedure”section.

Installation

1. Use the provided hardware to securely hang the Generator from an overhead support, such as a ceiling beam. Leave

 atleast20”betweentheunitandthewall,ceiling,orothersurfacesorobjects.Installthescrewhooksintothe  

overhead support, then use the S hooks to attach the chain to the unit and the screw hooks. Bend the S hooks

to secure the chain.

2.VerifytheGeneratorishanginglevel.Theunithasabuilt-intip-overswitch,apendulum-likesafetyfeaturethatwillturn

 offthegassupplytotheburnersiftheunittipsover,fallsorisn’tlevel.

3.Connecttheprovidedgasregulatortotheliquidpropaneornaturalgassupply.ThegassupplytotheGenerator 

 mustberegulatedtoaverylowpressure(11”WCor½psiforliquidpropane,and4.5”WCor¼psifornaturalgas).

4.Useawrenchtoconnectoneendoftheincluded12’hosetothearettingontheunitandtheotherendtothe 

provided gas regulator.

5.Toverifytheconnectionsaresecure,checkforleaksbysprayingasoapsolutionontothegasconnectionttingswiththe

 shut-offvalveinopenposition.Ifbubblesappear,closetheshut-offvalve,retightentheconnectionandrepeat

the process.

LEDIndicators

TherearefourLEDindicatorsonthesideoftheGenerator,nearthepowerswitch.

•The“MainPowerON”LEDilluminateswhenthepowersupplyisconnectedandtheunitisturnedon.

•The“LockOutError”LEDashestoindicatetheignitioncontrolmodulehasshutoffthesolenoidvalvesandtheunitwill

not operate until it has been disconnected from and reconnected to power.

•The“PilotValveON”LEDilluminateswhentheignitioncontrolmoduleprovidesasparkfor15secondswhilethepilot 

 solenoidisactivated.TheLEDwillremainilluminatedduringoperation.

•The“MainValveON”LEDilluminateswhentheamesensordetectsaame.LEDremainsonduringoperation.

Start-upProcedure

1.Beforeinitiatingthestart-upprocedure,verifythepowerswitchisoffandtheGeneratorisnotpluggedin.

2.Pressurizethegaslinesbyopeningtheshut-offvalvesonthegassupply.Testforgasleaks,especiallyifthisistherst

time the unit has been used.

3.PlugtheGenerator’s24-VDCpowersupplyintoa120Vpowersource.

4.Connecttheotherendofthe24-VDCpowersupplycordtotheinletjackontheGenerator.

5.Turnthepowerswitchon.TheLEDlabeled“MainPowerON”willilluminate.

6.Theignitioncontrolmodulewillattempttoignitetheburnersforapproximately5seconds.TheLEDlabeled“PilotValve

ON” will illuminate.

7.Theburnersmaynotigniteinitiallyifthisisthersttimetheunitisbeingused.After30seconds,theunitwillattemptto

 ignitetheburnersfor15seconds.Theunitwillcontinueuntiltheburnerignitesorforamaximumofveattempts.

8.Ifveunsuccessfulattemptsaremade,themodulewilllockitselfoutandtheLEDlabeled“LockOutError”  

 willilluminate.TurnofftheGenerator,closetheshut-offvalve,andwait5minutestoallowthegastodissipatebefore 

attempting to restart the unit.

9.Whentheburnershaveignited,lookundertheunittoconrmtheameisblueandsteady,resemblingaowerorstar.

•Immediatelyturnofftheunitiftheameappearsyellow,excessivelylarge,orweakandlazy.Highgaspressure

 orincorrectgastypemayleadtoyelloworexcessivelyhighames.Lowgaspressuremaycausesmallorweak

 blueames.

•AftertheGeneratorhasbeentestedwithallburnersoperating,connecttheGeneratortoacontrollerortimer 

 thatwillcontrolthefrequencyanddurationoftheunit’soperation.

Warning

ModifyingCO2Output

ItisstronglyrecommendedtouseacontrollerortimingdevicetoproperlymanagetheoutputoftheGenerator.Ifthisis

notpossible,theGenerator’sCO2andheatoutputcanbemodiedbyusingtheprovidedbrasspipeplugstoreducethe

numberofactiveburners.Additionalplugsmaybepurchasedseparately.TheSpecicationstableshowsthesizeofthe

growing area that is appropriate for each model as well as how much CO2and heat are produced at maximum capacity.

EachburnerreplacedwithabrasspipeplugwillreducetheGenerator’soutputby2.65cuft/hrofCO2and2,263BTUfor

astandardliquidpropaneunit,2.7cuft/hrofCO2and2,767BTUforastandardnaturalgasunit,2.1cuft/hrofCO2and

1,788BTUforahighaltitudeliquidpropaneunit,and2.4cuft/hrofCO2and2,455BTUforahighaltitudenaturalgasunit.

TheCGLP-10andCGNG-10featuretheabilitytovaryCO2outputwiththeipofaswitch.Themainpowerswitchactivates

the two burners nearest the electrodes, and two additional selector switches independently activate two separate banks

offourburnerseach.Brasspipeplugsarealsoprovidedforfurthermodication.Todeterminetheappropriatenumberof

burnerstoactivateforthegrowingarea,dividethesizeofthegrowingarea(incubicfeet)by1,000.Forexample:Activate

six burners in a growing area of 6,000 cu ft.

ElectronicIgnitionControlModule

TheGenerator’selectronicignitioncontrolmoduleproducesasparkthatlightstheburners,eliminatingtheneedforanopen

pilotameandprovidingconsistent,controlledstarts.Themodulecontrolsdualredundantsolenoidvalves.

HighAltitudeGenerators

High Altitude Generators are specially designed to operate and compensate for reduced oxygen levels at altitudes higher

than4,500ftabovesealevel.BTUandCO2outputs will be reduced because there is less oxygen in the air at high altitudes

(seeSpecicationstable).

A High Altitude Generator may be operated at altitudes as low as 2,500 ft above sea level, but the unit should be tested

before use to ensure all burners ignite correctly and consistently.

FAQ

• Ismellgasaroundthegenerator,isthatnormal?

 No.Turnoffthegassupplyimmediately.Donotturnonanyelectricaldevices.Ventilatetheareaandleaveuntilthegassmell 

 dissipates.Turnthegassupplybackon,thendeterminewheretheleakisbysprayingsoapywateronthegasconnections.Retighten

the connections where bubbles appear.

• Whatdoesaashing“LockOutError”LEDmean?

 Thegassupplymayhavebeeninterrupted.“LockOut”isasafetyfeatureactivatedwhenthepilotdoesnotigniteafterveattempts. 

 Whentheproblemhasbeenxed,resetthe“LockOut”byturningthepowerofffor30secondsandthenbackon.Theunitwillreset 

automatically after 20 minutes and attempt to ignite the burners.

• ShouldtheGeneratorproducebuzzingorsparkingnoises?

 TheGeneratorwillproducebuzzingorsparkingnoisesonlywhentheunitisattemptingtoignitetheburners.

• Whatshouldtheameslooklike?

 Theamesshouldburncleanandblue,resemblingaowerorstar.Donotoperatethegeneratoriftheameisyellow,excessively 

large, or weak and lazy.

• Doesitmatterwhichburnersarereplacedwiththepipeplug?

 Theburnernearesttheelectrodesmustremaininplace.Removeandreplaceburnersstartingwiththeburnerfarthestawayfrom

the electrodes.

Troubleshooting

• Whyisn’ttheGeneratorworkingandwhyaren’ttheLEDsilluminatingeventhoughthepowerisconnected?

 Thetip-overswitchmayhavebeentriggered.Toreset,tilttheunittothesideandlistenforaclickingnoise.Ensuretheunitislevelto

avoid triggering the switch.

• Whywon’ttheburnersigniteeventhoughtheunitisattemptingtoignitethem?

 Verifytheunitisgeneratingasparkandtheburnerclosesttotheelectrodesisactive.Ensuretherearenokinksortwistsinthegas 

 lineandthegassupplyisadequate.Turnoffthegasregulatorfor30seconds,thentryagain.

• Whyisn’ttheCO2levelincreasingtothedesiredppm?

 Checkforairleakageinthegrowingarea.DonotoperateexhaustfanswhileCO2is being produced.

• Whatifthegrowingareagetstoohumidorhot?

 Reducethesettingsonthecontrollerortimingdevice.Ifanoutputcontrolisnotbeingused,burnerscanberemovedandreplaced 

with the provided brass pipe plugs.

rev:92014

Blueprint®CO2GeneratorLimitedWarranty

WhatThisWarrantyCovers

Thiswarrantycoversdefectsinmaterialsandworkmanshipundernormaluse,withanyexceptionslistedbelow.

WhoThisWarrantyCovers

Thiswarrantyappliestotheoriginalpurchaserofthisproductwiththeoriginalproofofpurchase.

HowLongWarrantyCoverageLasts

Thiswarrantyisineffectforaperiodofthreeyearsfromtheoriginaldateofpurchase.

WhatThisWarrantyDoesNotCover

Thiswarrantydoesnotcoverdamageordefectsresultingfromtheimproperinstallation,alteration,abuse,accidentaldamage,unauthorized

repairormisuseofthisproduct.Misuseincludesbutisnotlimitedtooutdooruse.Thiswarrantydoesnotapplytocosmeticdefectsorother

defectsthatdonotaffectthefunctionalityoftheproduct,andisvoidiftheproducthasbeendamagedasaresultofre,ood,orothernatural

disaster.SunleavesGardenProducts(“Sunleaves”)shallnotberesponsibleforanyincidentalorconsequentialdamagesofanynature,including

damageorinjurycausedtootherproducts,machinery,buildingsorproperty;lossofprots,timeorproduct;orinconvenience.Thiswarrantyis

giveninlieuofallotherwarranties,expressorimplied,includingwithoutlimitationmerchantabilityandtnessforaparticularpurpose.

Somestatesdonotallowtheexclusionorlimitationofincidentalandconsequentialdamages,orlimitationsonhowlonganimplied

warrantylasts,sotheabovelimitation(s)maynotapplytoyou.

WhatSunleavesWillDo

IfSunleavesdeterminesthewarrantedproductisdefectiveinmaterialorworkmanshipduringthewarrantyperiod,thenSunleaves,atitsoption,

willeitherrepairorreplacetheproduct.Innoeventshallthecostofrepairorreplacementexceedtheoriginalpurchaseprice.

HowtoObtainWarrantyService

Returnthisproductalongwiththeoriginalproofofpurchasetotheplaceofpurchaseinaccordancewithstorepolicy.Theoriginalproofof

purchaseMUSTaccompanytheBlueprint®product for this warranty to be valid.

HowStateLawApplies

Thiswarrantygivesyouspeciclegalrights,andyoumayalsohaveotherrightswhichvaryfromstatetostate.

Fortechnicalsupportandwarrantyinformation,calltoll-free888-464-9676oremail[email protected].

Este manual sirve para los siguientes modelos

Manuales populares de Generador portátil de otras marcas

Kohler

Kohler 20EORZ Manual de instrucciones

Powerhorse

Powerhorse 83171 Manual de usuario

HURST

HURST ML-630-SI Manual de usuario

ETQ

ETQ TG4000 Manual de usuario

Briggs & Stratton

Briggs & Stratton 40265 Guía de configuración

ConMed

ConMed 7550 Manual de usuario

Owon

Owon Waveform Generator Manual de usuario

evertz

evertz 7700 Series Manual de usuario

Power Stroke

Power Stroke PS906025 Manual de usuario

Firefly

Firefly Cygnus CYG2400/460/24 Manual de usuario

Draper

Draper PG950S Actualización de firmware

PowerBoss

PowerBoss PowerBoss Manual de usuario

SDMO

SDMO SH 4000 Manual de usuario

EINHELL

EINHELL STE 5500 Manual de usuario

Wanco

Wanco WI3000P Manual de usuario

Full Boar

Full Boar FBT-3300 Manual de usuario

Dwyer Instruments

Dwyer Instruments ASG Manual de usuario

Westinghouse

Westinghouse WH1000i Series Manual de usuario