BIOBASIC 210 Manual de usuario

BIOBASIC

INSTRUCTIONS FOR USE

Models: 210, 310, 410 & 600

2 | BIOBASIC INSTRUCTIONS FOR USE

Before you proceed

This instructions for use is intended for the following product series:

BIOBASIC

We recommend that you read this instructions for use through thoroughly

before using the cabinet for the rst time. Gram Commercial does not

guarantee safe operation if the cabinet is used for anything other than its

intended use. Contents of the instructions for use can be subject to change

without notice. No part of this instructions for use may be reproduced in

any form without expressed written consent of Gram Commercial. Gram

Commercial guarantees the cabinet under certain warranty conditions. Gram

Commercial is not responsible for any loss or damage of content.

This instructions for use should be considered an integral part of the cabinet

and should be stored close to the cabinet and be easy to access. If the

instructions for use is lost, please refer to your local distributor or Gram

Commercial for a replacement. For current versions of the instructions for use,

please go to www.gram-bioline.com.

Gram BioLine equipment is designed to be used in a system with monitored

additional independent alarms to ensure timely reaction to alarms and thereby

maximum item safety

BIOBASIC INSTRUCTIONS FOR USE | 3

In the event of need for product support, donot hesitate to contact us at:

[email protected]

In the event of technical diculties always contact Gram BioLine technical

support or a Gram BioLine authorized service partner.

reserved. The content of this publication is owned by Gram BioLine, unless otherwise

noted, and is protected by Danish and international copyright laws and provisions.

Information and images may not be used, copied or transferred without the express

written permission by Gram BioLine.

4 | BIOBASIC INSTRUCTIONS FOR USE

Table of Content

Before you proceed ............................................. 2

Table of Content ................................................ 4

Intended use .................................................... 6

Temperature setpoint range and ambient requirements ......... 6

Symbols used ................................................... 7

Installation ..................................................... 8

Initial setup steps ............................................... 8

Adjusting the base .............................................. 9

Anti tilt bracket ................................................10

Wall mounting .................................................11

Surroundings ..................................................12

Product inspection ............................................13

Voltage free contact ...........................................14

Connecting to power ..........................................16

Equipotential bonding .........................................20

Start up ........................................................22

The digital display controls .....................................22

General introduction to the controller interface ................23

Alarm settings ................................................. 24

Buttons and useful short cuts ..................................25

Operation parameters .........................................26

Error codes ....................................................27

Latching alarms: A2, A3 ........................................27

Sensor oset ..................................................28

Ordinary use ...................................................30

Door gaskets ..................................................32

General info ...................................................33

Responsibility .................................................33

General info ...................................................34

Service ........................................................34

BIOBASIC INSTRUCTIONS FOR USE | 5

Type number plate ............................................35

Access port ....................................................36

Regular maintenance .........................................38

Cleaning .......................................................38

IMPORTANT ....................................................40

Disposal .......................................................41

Datasheet. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

General data: BIOBASIC 210, 310, 410 ..........................42

BIOBASIC RR210 – with solid door ..............................44

BIOBASIC RR210 – with glass door. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45

BIOBASIC RR310 – with solid door ..............................46

BIOBASIC RR310 – with glass door. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47

BIOBASIC RR410 – with solid door ..............................48

BIOBASIC RR410 – with glass door. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49

BIOBASIC RF210 ...............................................50

BIOBASIC RF310 ...............................................51

BIOBASIC RF410 ...............................................52

General data: BIOBASIC 600 ...................................54

BIOBASIC RR600 ............................................... 56

BIOBASIC RF600 ...............................................57

Declaration of Conformity .....................................58

Wiring diagrams ............................................... 59

BIOBASIC RR/RF210, RR/RF310, RR/RF410 ......................59

BIOBASIC RR600 ............................................... 60

BIOBASIC RF600 ...............................................61

Piping diagram ................................................62

Notes ..........................................................64

6 | BIOBASIC INSTRUCTIONS FOR USE

Intended use

BIOBASIC refrigerators (RR) and freezers (RF), are designed and manufactured

to provide general purpose storage of non-critical laboratory items.

The BIOBASIC range complies with EN/IEC 60079-15, covering electrical

apparatus in Category 3, Zone 2 locations where explosive atmospheres may be

present.

Enabling placement of BIOBASIC refrigerators and freezers, in Zone 2 areas

categorised according to EN/IEC 60079-14.

Temperature setpoint range and

ambient requirements

Model + temperature

setpoint range

Minimum ambient

operating temperature

Maximum ambient

operating temperature

BIOBASIC 210, 310, 410

RR with solid door: +2/+15ºC +10ºC +35ºC

RR with glass door: +2/+15ºC +10ºC +32ºC

RF: -25/-5ºC +10ºC +35ºC

BIOBASIC 600

RR: +2/+15ºC +10ºC +43ºC

RF: -25/-5ºC +10ºC +43ºC

The user must ensure that the cabinet is used in accordance with its

intended use. Abnormal use or use conicting with the intended use or

guidelines stipulated in the product documentation can lead to; danger

to patient safety, damage to stored items, damage to cabinet, danger to

user. Gram BIOBASIC equipment is designed to be used in a system with

monitored additional independent alarms to ensure timely reaction to

alarms and thereby maximum item safety.

BIOBASIC INSTRUCTIONS FOR USE | 7

Symbols used

Risk of burning / freezing

Risk of personal injury

Risk of material damage

Risk of electric shock

Hazard

Info

 Riskofre/ammable materials

Risk of explosion/explosive materials

ATEX information

8 | BIOBASIC INSTRUCTIONS FOR USE

Installation

Initial setup steps

The cabinet is shipped with a protective

lm that shall be removed prior to use.

WARNING – POTENTIAL

ELECTROSTATIC CHARGING

HAZARD

Removing protective packaging

and lm may cause electrostatic

discharge. protective packaging and

lm shall not be removed in ATEX

zones.

The cabinet is only allowed to lay down for very short durations (for instance

handling through a doorway). If the cabinet has been laying down, the

cabinet must stand up-right for at least 24 hours prior to use. This enables

oil in the compressors to run back into place.

Avoid placement of the cabinet in a chloric/acidic environment due to risk

of corrosion.

Due to safety and operating considerations, the cabinet must not be used

outdoors. The cabinet should be installed in a dry and suciently ventilated

area. To ensure ecient operation, the cabinet should not be installed in

direct sunlight or close to heat sources.

The cabinet interior must not be exposed to corrosive atmospheres.

Clean the cabinet with a mild soap solution prior to use.

BIOBASIC INSTRUCTIONS FOR USE | 9

Cabinets equipped with legs

should be levelled as shown in the

illustrations to the left.

For cabinets equipped with

castors, the oor must be level

to ensure stable positioning and

safe use. When the cabinet is

positioned, the 2 front castors

should be locked.

Adjusting the base

Cabinets with drawers and/or glass door must be secured to a stable vertical

surface, ensuring that the cabinet cannot tip over when the drawers are drawn

to the outermost position, or the door is open. Brackets for securing the cabinet

are included from the factory.

Find the instructions for the tilt bracket below.

The anti-tilt brackets must be tted when installing the cabinet, ensuring that

the users, surroundings and stored items are not damaged.

10 | BIOBASIC INSTRUCTIONS FOR USE

Anti tilt bracket

Este manual sirve para los siguientes modelos

Tabla de contenidos

Manuales populares de Congelador de otras marcas

Siemens

Siemens GU..D SERIES Manual de usuario

Omcan

Omcan FR-CN-0155 Manual de usuario

Beko

Beko FNE290E24W Manual de usuario

Electrolux

Electrolux ARCTIS G 8 60 50-6I Manual de usuario

Electrolux

Electrolux EUF2042AOX Manual de usuario

Dometic

Dometic CoolFreeze CFX95DZ Manual de usuario

Electrolux

Electrolux EUF7000W1 Manual de usuario

Polar Electro

Polar Electro CT330 Manual de usuario

MPM

MPM MPM-145-SK Series Manual de usuario

SAF

SAF PRESTOTIG 200AC/DC Guía rápida

Zanussi

Zanussi ZFT11407WA Manual de usuario

AEG

AEG A63190GT Manual de usuario

AEG

AEG A81000TNW0 Manual de usuario

Matsui

Matsui MUC50S15E Manual de usuario

NEFF

NEFF G4344X8 Manual de usuario

Frigidaire

Frigidaire FV 1246 H Manual de usuario

Frigidaire

Frigidaire FFC13K1AW Manual de usuario

Electrolux

Electrolux EU 2400C Manual de usuario