Becker AR6201 Series Guía

VHF-Transceiver

Family

AR6201-(X1X)

AR6201-(X2X)

RT6201-(X10)

RT6201-(X20)

RCU6201-(X1X)

AR6203-(X1X)

AR6203-(X2X)

Software Versions:

SCI1050S305 Version 3.07

SCI1051S305 Version 1.51

and upwards

Installation

Operation

Manual DV 14307.03

Issue 1 September 2013

Becker Avionics GmbH ●Baden Airpark B108 ●77836 Rheinmünster ●Germany

Telephone +49 (0) 7229 / 305-0 ●Fax +49 (0) 7229 / 305-217

http://www.becker-avionics.com ●e-mail: info@becker-avionics.de

AR6201

RCU6201

RT6201

AR6203

FIRST ISSUE AND CHANGES

Issue 1 September 2013

LIST OF EFFECTIVE PAGES

Page No.: Date: Page No.: Date:

Cover Page

09/2013

I … VIII

09/2013

1-1 … 1-20 09/2013

2-1 … 2-66 09/2013

3-1 … 3-20 09/2013

DV 14307.03 / Article Number 0638.404-071

AR6201 - RT6201 - RCU6201 - AR6203

DV 14307.03 Issue 1 09/2013 Page I

Preface

Dear Customer,

Thank you for purchasing BECKER products.

We are pleased that you have chosen our product and we are confident

that it will meet your expectations.

AR620X-(XXX) VHF Transceivers are a modern family of communication

equipment that have comprehensive capabilities and significantly extend

the typical aeronautical transceivers.

Despite its small size and weight 620X- aircraft radio include inter

alia:

•Sensitive receiver which meets the most recent requirements of ED-

23C, including the ability to work in the offset-carrier (climax)

operation in 25 kHz and 8.33 kHz channel spacing (class H2).

•Receiver that includes SCAN (dual watch) mode. This allows

simultaneous monitoring of two different VHF frequency channels

without interrupting communication on the active frequency.

•High efficiency transmitter which delivers more than 10W modulated or

un-modulated output power at 28V supply voltage or 6W at 12V. Low

power consumption allows longer operation from battery.

•Extended built-in intercom which can work as:

o4-way intercom with isolation mode – passengers could continue

conversation or listening to music from MP3 player at the same

time as pilots talk via intercom or communicate with the tower.

o2-way intercom for tandem operation – pilot and co-pilot work

with separate controllers and can control their individual

audio parameters, like volume or VOX. This mode is preferred

especially for training due to full synchronization of LCD

contents.

•Non-volatile memory for storing:

o99 VHF channels can manually be labeled for storage of VHF

channels

o9 recently selected VHF channels are automatically stored

AR6201 - RT6201 - RCU6201 - AR6203

Page II DV 14307.03 Issue 1 09/2013

Table of Contents

List of Abbreviations VI

Section 1 GENERAL DESCRIPTION 1-1

1.1 Introduction 1-1

1.2 Purpose of Equipment 1-1

1.3 General Notes 1-2

1.4 Variants Overview 1-2

1.5 Short Description 1-3

1.5.1 AR6201 Single Block Transceiver 1-4

1.5.2 RT6201 Remote Transceiver 1-4

1.5.3 RCU6201 Remote Control Unit 1-5

1.5.4 AR6203 Single Block Transceiver 1-6

1.6 Features Overview 1-6

1.7 Technical Data 1-9

1.7.1 Power Supply Data 1-9

1.7.2 General Data 1-10

1.7.3 Dimensions & Weight 1-11

1.7.4 Receiver Data for AR620X and RT6201 1-11

1.7.5 Transmitter Data AR620X and RT6201 1-12

1.7.6 Emergency Operation 1-12

1.7.7 Software 1-13

1.7.8 Complex Hardware 1-13

1.7.9 Regulatory Compliance 1-13

1.8 Environmental Qualification AR620X and RCU6201 1-14

1.9 Environmental Qualification RT6201 1-16

1.10 Accessories 1-18

AR6201 - RT6201 - RCU6201 - AR6203

DV 14307.03 Issue 1 09/2013 Page III

Section 2 INSTALLATION 2-1

2.1 Limitations 2-1

2.2 Unpacking the Equipment and Preparation for

Installation 2-1

2.3 Mechanical Installation 2-1

2.3.1 AR6201 and RCU6201 Installation 2-1

2.3.2 AR6203 Installation 2-3

2.3.3 RT6201 Installation 2-5

2.4 Electrical Interface 2-8

2.4.1 Connectors and Pin Assignment for AR6201, AR6203

and RT6201 2-8

2.4.2 Inputs / Outputs Detailed Description 2-11

2.4.3 Connector and Pin Assignment for RCU6201 2-16

2.5 Installation and Configuration of 620X Transceivers 2-17

2.6 Antenna Installation 2-18

2.7 Installation Setup for RT/AR6201-(X1X) 2-19

2.7.1 Entering Installation Setup 2-19

2.7.2 Leaving Installation Setup 2-19

2.7.3 Page Up / Page Down in the Installation Setup 2-19

2.7.4 Storage of Setup Data 2-19

2.7.5 Terminate Installation Setup 2-19

2.7.6 VU Meter 2-20

2.7.7 Installation Setup Pages - Data Description 2-20

2.8 Factory Default Settings 2-35

2.9 Typical Installations with Recommended Settings and

Wiring Diagrams 2-37

2.9.1 Single Seat Glider 2-37

2.9.2 Twin Seat Motor Glider 2-40

2.9.3 General Aviation (GA) Aircraft using Standard

Microphones 2-42

2.9.4 Installation Setup for individual dual headset

configuration (two IC circuit) 2-44

AR6201 - RT6201 - RCU6201 - AR6203

Page IV DV 14307.03 Issue 1 09/2013

2.9.5 Installation Setup for Twin Seat with AR6201 Tandem

Configuration 2-46

2.9.6 Wiring for Aircraft with Four Seats (no TANDEM) 2-48

2.9.7 Installation with RT6201 2-51

2.9.8 Aircraft with Intercom System 2-52

2.9.9 Installation Setup for Twin Seat with RT6201 Tandem

Configuration 2-55

2.10 Retrofitting an AR4201 with an AR620X 2-57

2.10.1 Pin Compatibility 2-57

2.10.2 Dynamic Microphone Input 2-59

2.10.3 Temperature Sensor 2-59

2.10.4 RS-232 Interface 2-59

2.10.5 AFCU/AGC/AFWB 2-60

2.10.6 CPIN 2-60

2.10.7 +13.75V Switched 2-60

2.10.8 PWR_EVAL 2-60

2.11 Post Installation Tests 2-60

2.11.1 Mechanical Installation and Wiring Check 2-60

2.11.2 Power Supply 2-60

2.11.3 Receiver / Transmitter Operation 2-61

2.11.4 Antenna Check 2-61

2.11.5 Interference Check 2-61

2.11.6 Flight Test Check 2-63

2.12 Trouble Shooting 2-63

2.13 Continued Airworthiness 2-65

AR6201 - RT6201 - RCU6201 - AR6203

DV 14307.03 Issue 1 09/2013 Page V

Section 3 OPERATION 3-1

3.1 Safety Instructions 3-1

3.2 Controls and Indicators 3-2

3.2.1 Controls 3-2

3.2.2 Symbols Shown on the Display 3-3

3.3 Start-Up 3-3

3.4 Receive and Transmit Mode 3-4

3.4.1 Receive Mode 3-4

3.4.2 Transmit Mode 3-4

3.5 Frequency Selection Modes 3-5

3.5.1 Standard Mode 3-5

3.5.2 Direct Tune Mode 3-6

3.5.3 Channel Mode 3-7

3.5.4 Scan Mode 3-9

3.6 Squelch 3-10

3.7 RX Field Strength Indication 3-10

3.8 Channel Spacing Mode 3-11

3.9 Storage Function 3-11

3.9.1 Manual Storage Function 3-11

3.9.2 Automatic Storage Function 3-13

3.10 Auxiliary Audio Input 3-13

3.11 Intercom Operation 3-13

3.12 VOX & Speaker Operation 3-15

3.13 Menus 3-15

3.13.1 Intercom Menu 3-15

3.13.2 Pilots Menu 3-17

3.14 Warning and Failure Indications 3-18

AR6201 - RT6201 - RCU6201 - AR6203

Page VI DV 14307.03 Issue 1 09/2013

List of Abbreviations

AC ..... Alternating Current

AF ..... Audio Frequency

AR ..... Airborne Radio

ATT .... Attenuation

AUX .... Auxiliary

AWG .... American Wire Gauge

BNC .... Bayonet Neill Concelman

CBIT ... Continuous Built-In Test

CFG .... Configuration

CH ..... Channel

CM ..... Chassis Module

COM .... Communication

DC ..... Direct Current

EASA ... European Aviation Safety Agency

EMI .... Electro Magnetic Interference

ETSO ... European Transmission System Operators

GND .... Ground (Aircraft Ground)

GPS .... Global Positioning System

HMI .... Human Machinery Interface

HIRF ... High Intensity Radiated Fields

IC ..... Intercom

I&O .... Installation & Operation

LCD .... Liquid Crystal Display

MFD .... Multi-Function Display

M&R .... Maintenance & Repair

N/A .... Not Applicable

NAV .... Navigation

PBIT ... Power-On Built In Test

PTT .... Push To Talk

PWR .... Power

RCU .... Remote control unit

Otros manuales para AR6201 Series

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Transceptor de Becker

Becker

Becker AR 3201 Manual de usuario

Becker

Becker AR6201 Series Manual de usuario

Becker

Becker COMM 2000 Manual del propietario

Becker

Becker AR6201 Series Manual de usuario

Becker

Becker RT6512 Manual de usuario

Becker

Becker AR 4201 Manual del propietario

Becker

Becker AR6201 Series Manual del propietario

Becker

Becker RT6512-100 Guía

Becker

Becker AR 4201 Instrucciones de funcionamiento

Becker

Becker AR6201 Series Manual de usuario

Becker

Becker AR6201 Series Manual de usuario

Becker

Becker AR 3209 Manual de usuario

Becker

Becker AR 4201 Manual de usuario

Becker

Becker RT6512 Manual de usuario

Becker

Becker AR620X Manual del propietario

Becker

Becker GT6201-05 Manual del propietario

Becker

Becker GT6201-05 Manual de usuario

Becker

Becker GK615 Series Manual del propietario

Becker

Becker AR6201 Series Manual de usuario

Becker

Becker 6200 Series Manual del propietario

Becker

Becker GT6201 series Manual del propietario

Becker

Becker AR 3209 Manual de usuario

Manuales populares de Transceptor de otras marcas

Yaesu

Yaesu FT-7B Manual de usuario

Kenwood

Kenwood ProTalk TK-3201 Manual de usuario

Texas Instruments

Texas Instruments TLK10232 Manual de usuario

Mizuho

Mizuho MX-2 Guía del producto

Kenwood

Kenwood TK-3180 Manual de operación y mantenimiento

Blitz

Blitz MJ-398U Manual de usuario

Utilicom

Utilicom LongRanger 2050 Manual de usuario

Standart

Standart HX290UKA Manual de usuario

Altronix

Altronix Pace1PTM Manual de usuario

Kirisun

Kirisun PT2208 Manual de usuario

ELECRAFT

ELECRAFT KX2 Manual de usuario

Zodiac

Zodiac K3 Manual de usuario

Assa Abloy

Assa Abloy SecureComm HKC GSM-WIFI U Manual de usuario

Kenwood

Kenwood TK-2217 Manual de usuario

Siemens

Siemens PSO 4000 Manual de usuario

Kenwood

Kenwood TS-590SG Manual de usuario

Midland

Midland G8E-BT Manual

ComNav

ComNav Mariner X2 Manual de usuario