Baja motorsports SC50-2 Manual

1. Remove cardboard carton

from metal frame.

2. Remove wire straps and foam

covering from handlebars.

Removal from Crate

SC50-2 Scooter Set up Instructions

3. Remove bolt holding metal

frame to rear of scooter.

4. Remove axle bolt holding metal

frame to front forks.

Rev C

051908

Removal from crate

5. Remove metal frame and parts

included for assembly.

Parts

Front fender Front wheel Front wheel spacer

QTY 1

QTY 4

QTY 1

NOTE: Pay attention to front

wheel spacer. Save this spacer

for installation of front wheel

Parts

Mirrors

Parts listed below found under seat

Tool Kit

Manufacturer Certicate

of Origin

Owners Manual

Battery Box

Floorboard cover/mat

Front Wheel

6. Align speed sensor between

front wheel and front fork.

8. Remove brake caliper spacer

before attaching brake caliper to

front wheel using bolts provided.

Spacer

Axle bolt

Speed sensor

Alignment groove

on front fork

7. Place front wheel spacer between disc

brake and fork on axle bolt. Attach front

wheel with axle bolt provided.

Torque to 33ft.lbs.

Front wheel

spacer

Alignment tab on

speed sensor

Handlebar

9. Attach handlebar assembly to stem

using bolt and nut provided.

Handlebar stem

NOTE: For easy installation place

nut on open end wrench.

Nut

Bolt

Open end wrench

Kick Stand

10. Remove cotter pin from kick stand bolt

Remove bolt. Save both cotter pin and

bolt for installation.

11. Attach kick stand to bottom of engine

using bolt previsouly removed.

12. Secure kick stand bolt using cotter

pin previously removed. Be sure to

bend each end of cotter pin over.

13. Attach both kick stand springs.

NOTE: Place small spring inside big spring.

One end on kick stand tab, the other end on

the engine tab. A screw driver will be needed

for leverage.

Mirrors

14. Insert left and right mirror into hole

on handlebar and turn clockwise, secure

by tightening nut .

Nut

Turn Signals

15. Attach left and right turn signals to

bracket located on handlebars.

Horn and Front Fender

17. Attach front fender. Line up tabs of fender with

slots on scooter. Secure with four phillip head

screws and one phillip head bolt and washer.

16. Connect the purple and green wire to

post on horn. NOTE: It does not matter

which post either wire is connected to.

Purple wire

Green wire

Rear Luggage Carrier

18. Secure rear luggage carrier using hardware provided.

NOTE: You will only need to install two of the three bolts as

bolt 1 is installed from the factory for shipping purposes.

Bolt 1

19. Refer to battery section of

owners manual for correct installation

and charging of battery.

Battery located in

oorboard under mat.

Battery Installation

WARNING

The following procedure is very dangerous and should be performed with utmost care and attention. Wear

protective eyewear, rubber gloves, and have water available should electrolyte come in contact with skin or

eyes. KEEP ALL CHILDREN AWAY FROM THE AREA WHILE THIS PROCEDURE IS BEING PERFORMED.

POISON – CAUSES SEVERE BURNS

Contains sulfuric acid.

Avoid contact with skin, eyes, or clothing

To prevent accidents, rinse empty container with water.

ANTIDOTE:

External – ush with water

Internal – Call physician immediately. Drink large quantities of water or milk.

Follow with milk of magnesia, beaten eggs or vegetable.

Eyes – Flush with water for 15 minutes and get prompt medical attention.

KEEP OUT OF REACH OF CHILDREN.

Tabla de contenidos

Otros manuales de Scooter de Baja motorsports

Baja motorsports

Baja motorsports RT50-R Retro Manual de usuario

Baja motorsports

Baja motorsports RT50-R 2009 Manual de usuario

Baja motorsports

Baja motorsports RT50-R Retro Manual

Baja motorsports

Baja motorsports RT150 Manual de usuario

Baja motorsports

Baja motorsports SC50 Manual de usuario

Baja motorsports

Baja motorsports SC150 HSun 150cc Manual de usuario

Baja motorsports

Baja motorsports SC50 Manual de usuario

Baja motorsports

Baja motorsports SC150 HSun 150cc Manual de usuario

Baja motorsports

Baja motorsports SC50 Manual de usuario

Baja motorsports

Baja motorsports SC150 HSun 150cc Manual

Manuales populares de Scooter de otras marcas

TEKTRO

TEKTRO CHEETAH Manual de usuario

Douglas

Douglas Vespa Sprint Guía de instalación

PLAYTIVE

PLAYTIVE AS-2448 Manual de usuario

Ebinger

Ebinger DONKEY XL Manual de usuario

Flyer

Flyer Mountain Guía del usuario

BackCountry eBikes

BackCountry eBikes Storm Manual de usuario

equipmed

equipmed FreeRoam II Manual de usuario

Yoto

Yoto Lion Manual de usuario

WESTHILL BIKES

WESTHILL BIKES LINK Manual de usuario

BAnff

BAnff eProdigy series Manual de usuario

Winther

Winther 475 Manual de usuario

Jetson

Jetson JBZL17 Manual de usuario

First Choice Mobility

First Choice Mobility Roma Medical Corella S741 Manual de usuario

Carrera

Carrera impel Manual de usuario

Afikim

Afikim Superlight SL-3 Manual de usuario

CareCo

CareCo ZOOM Manual de usuario

Douglas

Douglas Vespa G.S. Manual de usuario

Gazelle

Gazelle with BOSCH System Manual de usuario