AUTOTECH 10.202.401K-404K Manual de usuario

Installation Instructions

Part Number: 10.202.401-404K

Description: COLD AIR INTAKE SYSTEM, Mk4

Tools Required:

10mm. socket

Ratchet

12” extension

Phillips #2 screwdriver

Dremel type tool w. sanding drum (a half moon ﬁle will sufﬁce)

Warning:

This intake system places the engine air intake in a location that is only partially protected. Because of the low position

of the air ﬁlter relative to the ground, there is a risk of water ingestion into the engine if the car is run through deep

puddles, etc. Ingestion of a large enough amount of water can severely damage your car’s engine. For this reason, we

recommend that this Cold Air Intake System be used with caution, and at your own risk!

Procedure:

1. Remove battery cover

2. Remove battery hold down clamp

3. Remove plastic retainers on top of the battery

4. Disconnect battery terminals (always disconnect ground ﬁrst)

5. Remove battery

6. Using a 10mm. socket, remove the two bolts holding down the airbox

7. Remove the four bolts holding down battery tray

8. Remove battery tray

9. Using a short Phillips screwdriver, remove the two screws used to attach the mass air meter.

10. Disconnect breather hose from airbox

11. Remove airbox

12. Using 10mm. socket, remove the nut holding the ducting tube (nut will be re-used)

13. Using a phillips screwdriver, remove the ducting behind the driver’s side headlight

14. Remove the three plastic pushpin connectors on the remaining ducting

15. Remove ducting

16. With a small ﬁle or rotary sanding drum, clearance some of the plastic ﬂange at the rear of the headlight to make room for

the massive 3” tube

17. Install air inlet tube

18. Install silicone hose between the inlet tube and the airﬂow meter and tighten the supplied hose clamps

19. Install the nut on the body stud protuding through the bracket on the air inlet tube

20. Install the air ﬁlter from underneath

21. Re-install the battery tray

22. Re install the battery

23. Re-connect the battery leads (always connect ground last)

24. Re-attach the battery hold down

25. Re install the battery top covers and engine cover

26. Install the breather tube connector between air inlet tube and factory breather piping (pinch connectors to clip over nipples

1. Remove battery cover 2. Remove battery stay

4. Disconnect battery terminals 6. Using a 10mm socket, remove the....

...two bolts holding down the airbox 7. Remove the four bolts holding down the battery

tray

9. ... remove the mass air meter. 10. Disconnect breather hose

12. ...remove the ducting (nut will be reused) 13. ...remove ducting behind headlight

16. ...clearance rear of the headlight frame 17. Install air inlet tube

18. Install silicone hose ... ... And tighten clamps

19. Install the nut on the ﬂange of the tube

20. Install the air ﬁlter from underneath 21. Re-install the battery tray

24. Re-attach the battery hold down 26. Install breather tube connector

26. Install breather tube connector Completed installation

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Pieza de automóvil de AUTOTECH

AUTOTECH

AUTOTECH 10.215.352 363 Manual de usuario

AUTOTECH

AUTOTECH 10.215.200K Manual de usuario

AUTOTECH

AUTOTECH 10.430.301K 401K Manual de usuario

AUTOTECH

AUTOTECH 10.199.022K Manual de usuario

AUTOTECH

AUTOTECH 10.215.300 Manual de usuario

AUTOTECH

AUTOTECH 10.251.130K 10.251.131K Manual de usuario

AUTOTECH

AUTOTECH 10.715.200K 210K Manual de usuario

AUTOTECH

AUTOTECH 10.297.400K-402K 410K-412K Manual de usuario

AUTOTECH

AUTOTECH 10.215.455K Manual de usuario

AUTOTECH

AUTOTECH 10.715.014K 015K Manual de usuario

AUTOTECH

AUTOTECH 10.297.200K-205K Manual de usuario

AUTOTECH

AUTOTECH 10.297.500K-510K Manual de usuario

AUTOTECH

AUTOTECH 10.297.210K-214K Manual de usuario

AUTOTECH

AUTOTECH 10.215.340 351 361 Manual de usuario

AUTOTECH

AUTOTECH 10.199.500K Manual de usuario

AUTOTECH

AUTOTECH 10.297.220K-222K Manual de usuario

AUTOTECH

AUTOTECH 10.425.1025GK-1025K Manual de usuario

AUTOTECH

AUTOTECH 10.202.3011K 3021K Manual de usuario

AUTOTECH

AUTOTECH 10.202.3012K 3022K Manual de usuario

AUTOTECH

AUTOTECH 10.145.100K Manual de usuario

AUTOTECH

AUTOTECH 10.425.1125GK-1125K Manual de usuario

AUTOTECH

AUTOTECH 10.310.075K 080K Manual de usuario

Manuales populares de Pieza de automóvil de otras marcas

Dakota Digital

Dakota Digital 650277 Manual de usuario

bosal

bosal 037031 Manual de usuario

Edelbrock

Edelbrock 66332 Manual de usuario

Edelbrock

Edelbrock Honda XR400 Manual del propietario

Vintage Air

Vintage Air 571063 Manual de usuario

Edelbrock

Edelbrock 70005 Manual de usuario

GFB

GFB EX38 Manual de usuario

Edelbrock

Edelbrock 65272 Manual de usuario

bosal

bosal 028091 Manual de usuario

Dodge

Dodge 8W-43 Guía de inicio rápido

ICI

ICI Magnum FBM10DGN Manual de usuario

Volant Perfomance

Volant Perfomance 19435 Manual de usuario

BENDIX

BENDIX GEN 4 GEN 5 ABS Manual de usuario

Edelbrock

Edelbrock 72552 Manual de usuario

Edelbrock

Edelbrock 70024 Manual de usuario

Edelbrock

Edelbrock 6719 Manual de usuario

Edelbrock

Edelbrock 5486 Manual de usuario

Vintage Air

Vintage Air 571065 Manual de usuario