Atlantic Ultraviolet Eco-Logic Manual de usuario

Eco-Logic Manual.doc 8/12/2002

Operation Manual for Eco-Logic Pond & Lake Restoration System

1) Overview of System Operation

2) Safety Precautions

3) Eco-Logic Unit Specifications / Equipment Installation Recommendations

4) Recommended System Maintenance

5) Aeration Tubing Installation Guidelines

6) Vane Replacement

7) Eco-Logic features

8) Dimensional Data

9) Wiring Diagram

10) Plumbing Diagram

11) Ozone Cell parts Diagram

12) Warranty Card

Eco-Logic Manual.doc 8/12/2002

System Overview

The Eco-Logic Pond and Lake Restoration Systems are designed to aerate a body of water with a controlled

combination of air and ozone.

Ozone, a natural occurring form of oxygen, sometimes known as activated oxygen, is a powerful short-lived

oxidant, which is primarily used to disinfect drinking water.

Ozone and air are diffused into the lake bottom by means of a patented sinkable hose consisting of hundreds of

openings, which release the aeration mixture into the lake bottom. This process begins to circulate stagnant,

decaying matter on the bottom of the lakebed and begins breaking up the stratification of the lake's surface water

while increasing the lake's concentration of dissolved oxygen.

Safety:

Ultraviolet rays produced inside the ozone cell of this unit are harmful to eyes and skin. Never operate this unit

with the ultraviolet lamp exposed or removed from the ozone chamber.

The ozone generator should be installed in a properly ventilated equipment area with accessibility restricted to

authorized personnel only.

The ozone gas produced by this system is very corrosive; therefore it is advisable to check for any possible leaks

in the hoses, which inject this gas into your pond to insure ozone gas is only exiting under water.

Eco-Logic Manual.doc 8/12/2002

Eco-Logic Unit Specifications / Equipment Installation Recommendations:

Model 4:

a) CFM of Unit: 4 CFM

b) Maximum PSI of Unit: 15 PSI

c) Maximum Depth of Pond: 34 Feet Deep

d) Maximum Surface Area Size: 1 Acre or 43,560 Square Feet

e) Physical Sizes of Unit: 36 1/4” x 12 1/8” x 18”

f) Recommended Accessories: 100 ft. of feeder tubing (270008)

250 ft. of 3” aeration tubing (270009)

(2) Plug connector (271525)

(1) Tee connector (271538)

(6) Hose clamps (271542)

Equipment Installation Recommendations:

1) Electrical Power Required:

Model 4: 700 Watts or 6 Amps

2) Location Selection:

a) Units should be installed in a properly ventilated area.

b) The unit’s front panel should be accessible as well as the lamp access cover for lamp removal.

c) Air intakes on the bottom of unit should be a minimum of 12” off the floor.

d) For wall mounting, select a vertical structure, which will support the unit.

e) Floor mounts should be bolted to a cement pad.

f) For outside installations, if possible, locate the unit out of direct sunlight, keep the unit away from

any sprinkler path and away from the green.

3) Installer:

a) Follow all local and state electrical codes to choose the correct wire size for length of run and wire

protection.

b) Review Guidelines of Aeration Tubing Installation located in this manual.

Eco-Logic Manual.doc 8/12/2002

Recommended System Maintenance:

Maintenance recommendations listed below are based upon a normal installation. Maintenance requirements may

vary from site to site depending upon unit used and installation environment.

1) Compressors:

We recommend compressor vanes be replaced at least once per year of operation. (See Price Schedule for specific

part number and cost for the Compressor Vane Kits).

2) Aeration Tubing:

Aeration tubing should be cleaned off with a rag if flow ever appears non-uniformed on the Pond’s surface. This

can be done by removing the tubing from the pond and wiping off the tubing. This task can be performed from

either on shore or on board a boat.

3) Ozone Cell Lamp:

We recommend that the lamp be replaced every 10,000 hours of operation. (See Price Schedule for specific part

number and cost for the Ozone Cell Lamp).

4) Electrostatic Air In-Take Filter:

We recommend the filter be inspected once every 30 days for dirt build-up. The filter can be cleaned using soap

and water. Replacement is necessary when cleaning the filter can no longer can be achieved or the filter material

breaks down. (See Price Schedule for specific part number and cost for the In-Take Air Filter).

Tabla de contenidos

Otros manuales de Sistema de filtración de agua de Atlantic Ultraviolet

Atlantic Ultraviolet

Atlantic Ultraviolet MIN-6 Manual de usuario

Atlantic Ultraviolet

Atlantic Ultraviolet SANITRON Series Manual de usuario

Atlantic Ultraviolet

Atlantic Ultraviolet MIN-1.5 Manual de usuario

Atlantic Ultraviolet

Atlantic Ultraviolet Mighty Pure MP49C Manual de usuario

Atlantic Ultraviolet

Atlantic Ultraviolet Mighty Pure MP36C Manual de usuario

Atlantic Ultraviolet

Atlantic Ultraviolet Sanitron S50C Manual de usuario

Atlantic Ultraviolet

Atlantic Ultraviolet Mighty Pure MP13A Manual de usuario

Atlantic Ultraviolet

Atlantic Ultraviolet SANITRON S5000C Manual de usuario

Atlantic Ultraviolet

Atlantic Ultraviolet Bio-Logic BIO 1.5 Manual del propietario

Atlantic Ultraviolet

Atlantic Ultraviolet BIO 1.5 Manual del propietario

Atlantic Ultraviolet

Atlantic Ultraviolet Megatron M50 Manual del propietario

Atlantic Ultraviolet

Atlantic Ultraviolet MIN-9 Manual de usuario

Atlantic Ultraviolet

Atlantic Ultraviolet Mighty Pure MP16A Manual de usuario

Atlantic Ultraviolet

Atlantic Ultraviolet Mighty Pure MP22A Manual de usuario

Atlantic Ultraviolet

Atlantic Ultraviolet MIN-1 Manual de usuario

Atlantic Ultraviolet

Atlantic Ultraviolet S2400C Manual de usuario

Manuales populares de Sistema de filtración de agua de otras marcas

Wisy

Wisy LineAir 100 Manual de usuario

Schaffner

Schaffner Ecosine FN3446 Series Manual de funcionamiento

Pentair

Pentair FLECK 4600 SXT Guía del usuario

H2O International

H2O International H20-500 Manual de usuario

Renkforce

Renkforce 2306241 Manual de usuario

Neo-Pure

Neo-Pure TL3-A502 Manual de usuario

FLTR

FLTR OBF Manual de usuario

STA-RITE

STA-RITE VERTICAL GRID DE FILTERS S7D75 Manual de usuario

Applied Membranes

Applied Membranes W-G844EM Manual de usuario

BEGA

BEGA 116 Manual de usuario

WATA

WATA Standard Manual de usuario

Price

Price FFU series Manual

Gaggenau

Gaggenau BRITA INTENZA 467873 Manual de usuario

Brita

Brita SAFF-100 Manual de usuario

HEISSNER

HEISSNER FPU24000-00 Manual de usuario

BGS technic

BGS technic 1518 Manual de usuario

Reverse Osmosis

Reverse Osmosis RF Series Manual de usuario

ubbink

ubbink Filtramax Series Manual de usuario