Assa Abloy NORTON RIXSON CG0M19 Manual de usuario

IS-CG0M19 Rev 2 05/22

CG0M19 Intermediate Pivot

3/4" Offset, Handed

Installation Instructions

without the express written permission of ASSA ABLOY Accessories and Door Controls Group, Inc. is prohibited.

NORTON

RIXSON

Ce produit peut vous exposer au plomb qui, dans l’état de la

Californie, est reconnu pour causer le cancer, des anomalies

congénitales ou d’autres problèmes de reproduction. Pour plus

d’informations, visitez: www.P65warnings.ca.gov.

This product can expose you to lead which is known to the

state of California to cause cancer and birth defects or other

reproductive harm. For more information go to

www.P65warnings.ca.gov.

WARNING

1. Install intermediate pivot.

1. Determine hand of door for proper placement of

intermediate pivot. (Figure 1)

NOTE:

Door should already be hung with top pivot and

bottom pivot or floor closer.

Doors 60" - 90" (152.4cm - 228.6cm) in height

should use one Intermediate pivot; each

additional 30" (76.2cm) warrants an additional

Intermediate pivot.

2. Locate pivot(s) so that it is vertically in alignment

with centerpoint of top pivot and bottom spindle

and mark pivot leaf locations on door and frame.

(Figure 2)

3. Mortise door and frame. (Figure 3) Refer to

template IP50051.

4. Using pivot leaf as a template mark and prepare

mounting holes on door and frame. (Figure 3)

5. Install jamb portion of pivot in frame using five

(5) 1/4-20 x 5/8" FHMS or #14 x 1-1/2" FHWS screws

provided.

6. Install door portion of pivot in door using five (5)

1/4-20 x 5/8” FHMS or #14 x 1-1/2” FHWS screws

provided.

IMPORTANT: It is responsibility of door

and frame manufacturers to check

hardware schedule and prepare doors

and frames. The following instructions

cover field prep.

To Determine Your Hand of Door:

LH RH

Figure 1

1/8" (3.2) Minimum From

Face of Door to Door Stop

Door Stop

13/16" (20.6) From Face of

Jamb to of Pivot Pin

Door

Jamb

5/16

(7.9) 5/16

(7.9)

1/4

(6.8)

3/4" (19) From Face of

Door t L

o C of Pivot Pin

3/4" (19) From Door

Edge t

o C of Pivot Pin

Figure 3

Figure 2

Approved 2022-05-16

IS-CG0M19 Rev 2 05/22

without the express written permission of ASSA ABLOY Accessories and Door Controls Group, Inc. is prohibited.

CG0M19 Intermediate Pivot

NORTON

RIXSON

2. To adjust door height:

1. Remove arm cap and loosen locking screw of

bottom pivot arm. (Figure 6)

2. Remove hex cap from bottom of intermediate

pivot(s). (Figure 5)

3. Turn stud screw clockwise to raise the door to

desired height. (Figure 5)

4. Using shims furnished with bottom arm, fill gap

between arm and bottom pivot floor portion.

(Figure 6)

5. Turn stud screw counter clockwise until door rests

on shims. (Figure 5)

6. Tighten locking screw of bottom pivot. (Figure 6)

NOTE: Open and close door several times.

Make shim adjustments until door swings

freely.

7. Re-tighten locking screw and replace arm cap.

(Figure 6)

8. Replace hex cap of intermediate pivot. (Figure 5)

Hex Cap Shim

Locking Screw

Arm Cap

Arm Cap Screw

Stud Screw

Figure 5

Floor Portion

Spindle

Jamb

Portion

Top

Pivot

Intermediate

Pivot

1/8"

(3.2mm)

Clearance

Jamb

Door

Portion

Arm

Frame Header

Door

Floor

Door

Plumb Line

Figure 6

Right Hand Shown

Figure 4

Approved 2022-05-16

IS-CG0M19 Rev 2 05/22

without the express written permission of ASSA ABLOY Accessories and Door Controls Group, Inc. is prohibited.

CG0M19 Intermediate Pivot

NORTON

RIXSON

Template IP50051

NortonRixson.com

TEMPLATE NUMBER REV DATE

02/22

NORTON

RIXSON

NORTON

RIXSON

3/8

9.5

1-7/16

(36.5)

2-1/2

(63.5)

3-9/16

(90.5)

4-5/8

(117.5)

1-15/16

(49.2)

1-1/8

(28.6)

13/16

(20.6)

5/16

(7.9)

(127)

7/16

(11.1)

1-1/8

(28.6)

2-1/2

(63.5)

3-7/8

(98.4) 4-9/16

(115.9)

3-15/32

(88.1)

1-17/32

(38.9)

1-1/8

(28.6)

5/16

(7.9)

13/16

(20.6)

2-1/8

(54)

DOOR LEAF JAMB LEAF

NOTES:

Do not scale drawing.1.

Dimensions are given in inches (mm).2.

Pivot drilled for 1/4-20 x 5/8" FHMS or #14 x 1-1/2" FHWS.3.

Right hand shown. Left hand opposite.4.

2-3/32

(53.2)

CG0M19 Intermediate Pivot

3/4" Offset Hung

IP50051

Reproduction in whole or in part without the express written permission of ASSA ABLOY Accessories and Door Controls Group, Inc. is prohibited.

1/8

(3.2)

13/16

(20.6)

R 3/16

(4.8)

5/16

(7.9)

5/16

(7.9)

1/4

(6.4)

3/4

(19.1)

3/4

(19.1)

VIEW FROM BOTTOM OF DOOR LOOKING UP

SECTION A-A

SCALE 1 : 1

Bevel Edge Of Door

1/8" in 2"

(3.2 in 50.7)

Door

Frame

Min. Clearance

Approved 2022-05-16

IS-CG0M19 Rev 2 05/22

Norton Rixson is a brand associated with ASSA ABLOY Accessories and Door Controls Group, Inc., an ASSA ABLOY Group

in part without the express written permission of ASSA ABLOY Accessories and Door Controls Group, Inc. is prohibited.

Technical Product Support:

Monroe, NC 28112 USA

Phone: 877.974.2255 ext: 2

Techsupport.NortonRixson@assaabloy.com

NortonRixson.com

NORTON

RIXSON

Approved 2022-05-16

Otros manuales de Cerradura de puerta de Assa Abloy

Assa Abloy

Assa Abloy 1264 Manual de usuario

Assa Abloy

Assa Abloy IKON eCLIQ SPARK N112 Manual de usuario

Assa Abloy

Assa Abloy MSL mFlipLock basis Manual de usuario

Assa Abloy

Assa Abloy DC340 Manual de usuario

Assa Abloy

Assa Abloy Harmony H1 Manual de usuario

Assa Abloy

Assa Abloy ABLOY EL654 Manual de usuario

Assa Abloy

Assa Abloy Yale YDM3115A Manual de usuario

Assa Abloy

Assa Abloy PADDE Series Manual de usuario

Assa Abloy

Assa Abloy Yale nexTouch Especificaciones técnicas

Assa Abloy

Assa Abloy Yale PBS1 Manual de usuario

Assa Abloy

Assa Abloy CLIQ eCLIQ Connect key Manual de usuario

Assa Abloy

Assa Abloy effeff 827A-IP Manual de usuario

Assa Abloy

Assa Abloy Corbin Russwin HP3000 Series Manual de usuario

Assa Abloy

Assa Abloy eCLIQ Manual de usuario

Assa Abloy

Assa Abloy Sargent KP Series Manual de instalación

Assa Abloy

Assa Abloy Corbin Russwin ED2400 Series Manual de usuario

Assa Abloy

Assa Abloy effef 118 Manual de usuario

Assa Abloy

Assa Abloy Corbin Russwin SN Series Manual de usuario

Assa Abloy

Assa Abloy Sargent PE80 Series Manual de usuario

Assa Abloy

Assa Abloy Sargent Harmony Series Manual de usuario

Assa Abloy

Assa Abloy Corbin Russwin Access 600 CL33600 TCRNE1... Manual de usuario

Assa Abloy

Assa Abloy Corbin Russwin SE LP10 Series Manual de usuario

Assa Abloy

Assa Abloy mFlipLock standard Manual de usuario

Assa Abloy

Assa Abloy HES 9400 Instrucciones de funcionamiento

Manuales populares de Cerradura de puerta de otras marcas

We.lock

We.lock SECBNEBL51 Manual de usuario

Iseo

Iseo MA1A Manual de usuario

ID Lock

ID Lock 150 Manual de usuario

Lockly

Lockly ACCESS TOUCH PRO Manual de usuario

iLoq

iLoq G50S Manual de usuario

SDC

SDC Z7835 Manual de usuario

ilco

ilco 452 Manual de usuario

Samsung

Samsung shs-h705 Manual de usuario

TRU-BOLT

TRU-BOLT 08102017 Manual de usuario

CDVI

CDVI 500-LADJ Manual de usuario

Igloohome

Igloohome Deadbolt 2S Metal Grey Instrucciones de instalación y mantenimiento

eSSL

eSSL FL-300 Manual de usuario

JAKO

JAKO JKBTNX4 Manual de usuario

Dorma

Dorma MUNDUS PREMIUM GK 50 Guía del usuario

SCOOP

SCOOP Pullbloc 4.1 FS Panik Manual de usuario

Yale

Yale MORTISE 8800 SERIES Manual de usuario

Siegenia

Siegenia KFV AS3500 Manual de usuario

Saflok

Saflok Quantum ädesē RFID Manual de usuario