Antunes GST-1H Manual de usuario
Belt Removal:
1. Press and release the Power button to turn the unit
off. The Tortilla Warmer enters a cool-down mode.
Wait until the unit automatically shuts down and
OFF appears on the display.
2. Unplug the power cord.
3. Wearing heat resistant gloves, remove the all
accessories, Top cover (if applicable) feeder, chute,
rear panel and set aside (Figure 1)
Figure 1.
(Accessories may be different depending on model number)
4. Facing the front of the unit, move to the right side
panel. Rotate the unit as necessary for access.
5. Unlock the side panel door using a screwdriver,
coin, or similar tool. Open the side panel (Figure 2).
®
GST BELT REPLACEMENT INSTRUCTIONS (P/N 1012999)
Figure 2.
General
If you experience any problems with these instructions, con-
tact the factory Technical Service Department at 630-784-1000
or toll free in the U.S. at 877-392-7854.
WARNING
Turn the unit off, unplug the power cord and allow the
unit to cool down before performing any service or
maintenance on the unit.
ANTUNES www.antunes.com 180 Kehoe Blvd., Carol Stream, Illinois 60188
TOOLS: Heat Resistant Gloves, Flat Head Screw Driver,
Clean Sanitized Towel and Approved Sanitizer
PARTS INCLUDED
Main Belt Replacement Kit
1 Pack: P/N 7001766
2 Pack: P/N 7001659
Instruction Sheet: P/N 1012999
AFFECTED PRODUCTS: GST-1H
TOP COVER
FEEDER
CHUTE
HEATED LANDING ZONE
CLIP
BACK PANEL
BOTTOM
FRONT
ROLLER
SIDE
PANEL
DOOR
LOCK
LEVER
TOP
FRONT
ROLLER
Figure 3.
LIFT THIS
BRACKET
6. TOP BELT:
Remove tension on the Top Belt by pushing the Top
FRONT Roller IN and UP until it locks into position.
7. BOTTOM BELT:
Remove tension on the Bottom Belt by pushing the
Bottom FRONT Roller IN and DOWN.
8. Rotate the knobs shown in gure 3 half turn.
NOTE: If your unit came with clips attached to
the knobs, remove and discard them
9. Lift up on the tension brackets until it locks in the up
position and does not drop down. Repeat process
for opposite side of unit.
KNOB
LOCK LEVER
1
®
P/N 1012999 Rev. A 03/19
NOTE: If the brackets will not move, rotate the knobs
from Step 8 a half turn until the brackets can be
lifted up.
10. Disengage the lock lever by pulling it towards you
while lifting up on the bracket (Figure 3)
11. Slide the Belt(s) to be replaced out of the unit and
discard (Figure 4).
12. With belt(s) removed, wipe all expopsed rollers and
the top and bottom heater cover plates with a clean
sanitized towel to remove any debris (Figure 4).
NOTE: Any debris stuck on the roller/ cover plates
can damage the belts.
GST-BELT REPLACEMENT INSTRUCTIONS (P/N 1012999)
ANTUNES www.antunes.com 180 Kehoe Blvd., Carol Stream, Illinois 60188
Figure 4.
Installing Belts:
1. Wipe both sides of the new Belt(s) with a clean,
sanitized towel sprayed with an approved sanitizer
and allow to air dry.
2. BOTTOM BELT:
Slide the new bottom belt over the bottom rollers
(Figure 4).
3. TOP BELT:
Slide the new top belt over the top rollers (Figure 4).
and allow to air dry.
NOTE: You may need to lift the upper roller
assembly when installing the belts.
NOTE: Make sure the snaps are aligned evenly
on the rollers. The snaps on the belts should
face inside and should be aligned with the
grooves on the roller. Belts must be installed so
the exposed diagonal seam of the belt is away
from the direction of belt travel.
4. Restore tension on the bottom belt by pushing UP and
OUT (Figure 2)
6. Restore the tension on the top belt by pushing DOWN
and OUT (Figure 2)
7. Lock the brackets shown in Figure 5 by rotating the
highlighted knob so the brackets drop down into
place. Push down on each bracket to ensure they are
in position.
8. Engage the lock lever as shown in Figure 3.
Make sure the lock lever is properly inserted into the
slotted grooves.
9. Close and lock the side panel (Figure 7).
Figure 5.
CLIP
CLIP
KNOB
KNOB
LEFT
BRACKET
RIGHT
BRACKET
Figure 7.
10. Reinstall the accessories (Figure 3).
11. Plug the power cord into the appropriate outlet, turn
the unit on. Return the unit to use
2
®
P/N 1012999 Rev. A 03/19
Otros manuales para GST-1H
1
Otros manuales de Tostadora de Antunes
Antunes
Antunes HEBT-3V Manual de usuario
Antunes
Antunes 9210875 Manual de usuario
Antunes
Antunes VCT-20 Manual de usuario
Antunes
Antunes VCT-20 Manual de usuario
Antunes
Antunes VCT-2 Manual de usuario
Antunes
Antunes HEBT-5V Manual de usuario
Antunes
Antunes Roundup DST-200 Manual de usuario
Antunes
Antunes Roundup VCT-2000 Manual de usuario
Antunes
Antunes VCTM-2 Manual de usuario
Antunes
Antunes VCT-1000 Series Manual de usuario
Antunes
Antunes Gold Standard Toaster GST-2H Manual de usuario
Antunes
Antunes GST-3V Manual de usuario
Antunes
Antunes VCT-2 Manual de usuario
Antunes
Antunes Roundup VCT-2000 Manual de usuario
Antunes
Antunes 9210970 Manual de usuario
Antunes
Antunes Roundup VCT-2000 Manual de usuario
Antunes
Antunes VCT Series Manual de usuario
Antunes
Antunes Chick-fil-A RT-2 Manual de usuario
Antunes
Antunes VCT Series Manual de usuario
Antunes
Antunes Roundup VCT-2000 Manual de usuario
