Amcor DSR-12/20 Manual de usuario

DEHUMIDIFIER

DSR-12/20 DSRT-20

General information - Exploded view - Parts list

For safety reasons, read this information carefully before operating. Persons who

are not familiar with this type of product must not use it. We strongly recommend

keeping this information in a safe place for future reference.

This appliance must be earthed. The unit is designated for indoor operation.

Refer to the rating plate for voltage and power input. The installation must be in

accordance with regulations of the country where the installation is performed.

The minimum distance between air inlet(s) and/or air outlet(s) and any object must

be 40 cm.

* The unit is safe. However, as with other electrical appliance, use it with care.

* Keep out of reach of children.

* Do not clean the unit by spraying it or immersing it in water.

* Do not insert any object into an opening of the unit.

* Disconnect from the mains before cleaning the unit or any of its components.

* Never connect to an electrical outlet using an extension cord. If an outlet is not

available, one should be installed by a licensed electrician.

* Any service other than regular cleaning or filter replacement should be performed

by an authorized service representative. Failure to do so could result in a loss of

warranty.

* When the unit is placed in a (swimming) pool, connect to the mains via a

transformer or a breaking switch, conform the regulations regarding electrical

installations.

SAFETY

This product is not

made for DIY repair

Close to a heat

source

If the power cable

wires are frayed

or cut

When small

children may be

left unattended

If an extension

cord is needed to

reach an outlet

Where the power

cable may be

damaged

Where it may

be damaged by

chemicals

Where there is a

risk of interference

by foreign objects

If there is a risk of

liquid falling on

the unit

Do not use your dehumidifier under the following conditions:

Reminder:

Waste electrical products must not be disposed of with household waste.

This product should be taken to your local recycling centre for safe treatment.

The unit can be supplied with a cord and an earthed plug. If it ever becomes

necessary to replace this plug, be sure to use an earthed plug suitable for the power

supply in your area and conform your national safety standard.

The wires of the cable are coloured in accordance with the standard electrical code.

BLUE NEUTRAL

BROWN LIVE

GREEN/YELLOW EARTH

The BLUE (NEUTRAL)wire should be connected to the terminal in the plug marked N

or coloured black.

The BROWN (LIVE)wire should be connected to the terminal in the plug marked L or

coloured red.

The GREEN/YELLOW (EARTH)wire should be connected to the terminal in the plug

marked E or coloured green or marked with this symbol :

The unit must be connected to the power supply with the appropriate leads.

The cord should pass through holes with rubber grommets.

Properly fused disconnect switches must be installed between the unit and the

power source.

The unit must be wired with an isolation (mains) switch accessible from outside

the wet area in which the unit is installed, to comply with IEE regulations.

ELECTRICAL WIRING

Attention! 3 minutes delay on all units with ‘Alfa-14’ controller.

When starting or restarting the unit, it will take 3 minutes before the compressor

and the fan will start running.

You can’t control humidity and haze outdoors.

But in an indoor swimming pool and other humid interior spaces where hot stuffy

air, steamy windows and walls are frequent phenomena, you can.

That’s why you need Amcor.

Amcor’s dehumidifiers clear the air in damp interior spaces.

Condensation is removed from windows, walls and ceilings.

Vaporous stuffy air is drawn off, clean air is pumped back in.

You simply set the dial and the air humidity remains at the required level.

And, the Amcor dehumidifier is an energy saver.

Water evaporating from a swimming pool, bathroom, archive, store or from wet

objects and surfaces increases the humidity of the air and creates the hazy and

stuffy air often found in the hall.

At the same time water condenses on the cooler parts in the hall: windows, walls,

ceilings, etc.

Water condensation is not only an aesthetic defect, it can, in the long run, cause

structural damage.

There are two methods for drying the air in humid spaces:

- by ventilation,

- by heat pumps.

The Amcor dehumidifier is designed as a heat pump and has, through energy

saving, a considerable advantage over a ventilation system.

The fan (1) sucks the humid air

through the evaporator (2). There

the air is cooled and the moisture

in the air condenses into water. This

water is collected in the tray (3) and

drained away through the sump and

piping.

The compressor (5) pumps the heat,

which has been extracted from the

air, into the condenser (6). There, this heat is once again released, and absorbed by

the dry air. The ready wired control box monitors and controls the operation.

AMCOR DEHUMIDIFIERS

HOW THE AMCOR DEHUMIDIFIER WORKS

The Amcor pool dehumidifier is

a ready to install, transportable,

appliance. It can be mounted on a

wall or ceiling console in the pool

room or even over a shower booth. It

may be mounted in adjoining rooms

and connected by ducts to the pool

room.

Amcor has not adapted normal room

air-conditioners for use in indoor

swimming pools, but has developed

pool dehumidifiers particularly

for this purpose. The compressor

therefore matches exactly the capacity of the evaporator, thus achieving the optimal

balance between efficiency and power consumption. The pool dehumidifier is

controlled by a humidistat which operates at a low (=safety) voltage of 24 V.

The relative humidity in an indoor swimming pool can be adjusted between

50 – 80 % when an external hygrostat is used.

Model DSR

INDOOR SWIMMING POOL DEHUMIDIFIERS

The minimum distance between

inlet(s) and/or outlet(s) and any

object must be 40 cm. Installation

of the dehumidifier is easy, as the

unit is built on a base and slides out

of the housing. The individual parts

are logically arranged and can be

inspected.

First, remove the screws of the frame

with louvres.

Remove the screws on the base.

Now the unit can be taken out the

housing.

Prepare a suitable console and

mount it on the wall.

Mount the housing on the console

and attach it by fastening its base

with screws to the legs (which should

preferably be lagged with a vibration

dampening material). Insert the unit

into the housing, fasten the housing to the base and attach the louvred frame in

front of the housing.

Attach a 3/4” I.D. flexible pipe to the drain nipple located at the back of the

dehumidifier.

INSTALLING MODEL DSR/DSRT

The appliance is actually maintenance free, except in cases of soiling. In this case

the filter has to be cleaned.

To take the filter out, unscrew 2 screws fastening the filter grid, located at the back.

Swing the grid towards you and up in order to get access to the filter. Remove the

filter. Hold it under a water tap and flush it clean with a stream of water. Let the

trapped water drip off the filter fabric and replace the dried filter in reverse order.

MAINTENANCE

Min. working temperature 5 °C , max. working temperature 35 °C.

Relative humidity 40 – 100 %.

OPERATING RANGE DSR-12/20

20 21 24 25 26 27 28

38 16

PART NO. QTY. PART NAME NO.

A436844 1CASING 1

468038 1GRID 2

A436536 1AIR-FILTER 3

A436334 1FRAME 4

A434632 1EVAPORATOR DSR-12 5

A434642 1EVAPORATOR DSR-20

A414305 1TOP COVER 6

A342695 1WALL RIGHT 7

A528644 1LOUVRES (IN) 8

508002 2CLAMP 9

EXPLODED VIEW

PART NO. QTY. PART NAME NO.

68038 1LOUVRES (OUT) 10

A436324 1FRONT 11

A434664 1COVER CONTROL BOARD 12

A492474 1CONTROL BOARD 13

A342705 1WALL LEFT 14

A434276 1CAPILLARY DSR-12 15

A434576 1CAPILLARY DSR-20

A326504 1CHASSIS 16

292026 1STRAINER – DISTRIBUTOR 17

A342725 1LEFT BULKHEAD 18

X1002110542 1EVAPORATOR DSR-12 19

X1003140542 1EVAPORATOR DSR-20

X1003190562 1CONDENSER DSR-12 20

X1004190562 1CONDENSER DSR-20

274312 1COMPRESSOR DSR-12 21

274314 1COMPRESSOR DSR-20- – 1 PH

271317 1COMPRESSOR DSR-20 – 3 PH

271283 1FAN MOTOR+HOUSING DSR-12 22

271284 1FAN MOTOR+HOUSING DSR-20

A328675 1DRAIN PAN 23

DEPEND OF COMP. RUBBER GROMMET 24

DEPEND OF COMP. SLEEVE 25

O81071 WASHER 26

O81075 SPRING WASHER 27

OO4025 NUT 28

295060 1LEVER SWITCH 29

294012 6GROMMET 30

294010 4GROMMET 31

DEPEND OF COMP. CAPACITOR - COMPRESSOR 32

275031-34 TERMINAL 33

429171 CONTACTOR DSR-3PH 34

482301 1TRANSFORMER 35

386117 1DEFROST CONTROL 36

346518 SEAL FOAM STRIP 37

508027 2LINE CORD CLIP 38

326101 1FUSE 1A 39

275016 1TERMINAL FUSE 40

DSR-20/DSRT-20 Moisture removal (L/24h)

at different room temperatures and different relative humidity levels

RH % 85 80 75 70 65 60 55 50

Temp °C

15 69 62 57 52 46 41 23 17

20 96 87 79 72 64 57 51 45

24 121 110 100 91 81 72 64 57

25 128 116 106 96 85 76 68 60

26 134 122 111 101 90 80 71 63

27 141 128 116 106 94 84 74 66

28 147 134 121 110 98 87 78 69

29 153 139 127 115 103 91 81 72

30 160 145 132 120 107 95 85 75

32 166 151 137 125 111 99 8 78

35 173 157 146 130 116 103 92 82

MOISTURE REMOVAL

DSR-12 Moisture removal (L/24h)

at different room temperatures and different relative humidity levels

RH % 85 80 75 70 65 60 55 50

Temp °C

15 41 37 34 31 28 25 23 17

20 57 52 48 43 38 34 30 27

24 73 66 60 55 49 43 39 34

25 77 70 6 58 81 46 41 36

26 80 73 67 60 54 48 43 38

27 84 77 70 63 56 50 45 40

28 88 80 73 66 59 52 47 42

29 92 84 76 69 62 55 49 43

30 96 87 79 72 64 57 51 45

32 100 91 82 75 67 59 53 47

35 104 94 86 78 69 62 55 49

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Deshumidificador de Amcor

Amcor

Amcor HD220 Manual de usuario

Amcor

Amcor Ad 140 Manual de usuario

Amcor

Amcor System QT 120 Manual de usuario

Amcor

Amcor SD12 Manual de usuario

Amcor

Amcor AD 400E Manual de usuario

Amcor

Amcor DC 14 Manual de usuario

Amcor

Amcor AHD-65E Manual de usuario

Amcor

Amcor D850E Manual de usuario

Amcor

Amcor AM-DD8L Manual de usuario

Amcor

Amcor D-850 Manual de usuario

Amcor

Amcor D-1000 Manual de usuario

Amcor

Amcor PLDM 16E Manual de usuario

Amcor

Amcor PLDA 25EH Manual de usuario

Amcor

Amcor AM-DD8L Manual de usuario

Amcor

Amcor MD280 Manual de usuario

Amcor

Amcor TC 120 Manual de usuario

Amcor

Amcor HD220H Manual de usuario

Amcor

Amcor DES 80 Manual de usuario

Amcor

Amcor HD 2000HT Manual de usuario

Amcor

Amcor AD12 Manual de usuario

Amcor

Amcor MD250 Manual de usuario

Amcor

Amcor D850E Manual de usuario

Amcor

Amcor A D100Y Manual de usuario

Amcor

Amcor SD12 Manual de usuario

Manuales populares de Deshumidificador de otras marcas

Daitsu

Daitsu CD031IU-DFA Manual de usuario

Fehom

Fehom PDGT701BE Manual de usuario

Hitachi

Hitachi RD-190GX Manual de usuario

Westpoint

Westpoint MDF1-30AE Manual de usuario

SOLIS

SOLIS easy dry compact Manual de usuario

ENVIROBOSS

ENVIROBOSS EB240 Manual de usuario

Sinclair

Sinclair R-9112 Manual de usuario

Kenmore

Kenmore 580.54701 Manual de usuario

Demargo

Demargo DM828NF Manual de usuario

Altrad Lescha

Altrad Lescha LDH 600 Manual de usuario

BOMANN

BOMANN LE 1150 CB Manual de usuario

SPT

SPT SD-46 Manual de usuario

REMKO

REMKO SLN 40 Manual de usuario

Haier

Haier HD458 Manual de usuario

Logik

Logik L20DHW12 Manual de usuario

Frigidaire

Frigidaire FDR30S1 - 30 Pint Capacity Dehumidifier Guía de inicio rápido

Blitz

Blitz HHD Series Manual de usuario

Prem-I-Air

Prem-I-Air PD14DEN Manual de usuario