"HD 14" LUBRICATION AND SERVICE CHART
1.
FAN - One lubrication point. Lubricate 17.
every 200 hours of operation with pres-
sure gun lubricant.
GENERATOR - Two lubrication pOints. Lu-
bricate every 200 hours of operation
with light motor oil. 18.
2.
3.
SECONDARY OIL FILTER - Install
element in the secondary filter
240 hours of operation or every
oil change. Refer to Topic 10.
a new
every
fourth 19.
20.
4.
CRANKCASE 13AYONNET GAUGE - Inspect oil
level every 10 hours of operation.
THROTTLE LEVER DISC - Lubricate when
necessary for easy operation with pres-
sure gun lubricant; do not over-lubricate.
FRONT IDLER - Two lubrication pOints.
Lubricate every 200 hours of operation
with
18
strokes of the gun. Use approved
motor oil. Refer to Topic 7.
STARTER - Two lubrication points. Lu-
brica te every 200 hours of opera tion
with light motor oil.
CLUTCH SHIFTI<.:RBEAlUNG -Lubricate every
10 hours of operation with pressure
gun
lubricant of high heat resistance.
TRACK SUPPORT ROLLER - Two lubrication
points. Lubricate every 200 hours of
operation with 10 strokes of the gun.
Use approved motor oil. Hefer to Topic
8.
STABILIZER CEANK ASSEMBLY - Twelve lu-
brication points. Lubricate every 10
hours of operation with pressure gun lu-
bricant.
TRACK RELEhSE SPEING MECHANISM--Inspect
011
level every 200 hours of operation.
Keep filled to filler plug with motor
oil same viscosity as used in trans-
mission. Drain, flush and refill with
motor oil same viscosity as used in
transmission every BOO hours of opera-
tion. Capacity 13 quarts.
TEUCK WHEELS--Ten lubrication points.
Lubricate every 200 hours of operation
with B-l/2 strokes of the gun. Use ap-
proved motor oil. Refer to Topic 6.
BELL CRANK THHUST PIN - Two lubrication
points. Lubricate every 10 hours of op-
eration with pressure gun lubricant.
STEEEING CLUTCH THROVlOUT BEAEING - Four
lubrication pOints. Lubricate every 10
hours of operation with pressure gun
lubricant of high heat resistance.
FINAL DHIVE DRAIN PLUG - Drain flush,
and refill every ;~OOto 400 hours of op-
eration. Capacity B quarts each.
FINAL DElVE FILLE.:ll,.PLUG -- Inspect oil
level every 10 hours of operation. Keep
filled to level of filler elbow with
approved motor oil.
5.
6.
7.
B.
9.
10.
11.
12.
13.
14.
15.
16.
5
21.
SEDIMENT TRAPS - Drain traps every mor-
ning before starting, or more often if
necessary. In freezing weather, drain
after stopping so water will not freeze
in traps.
FIRST STAGE FUEL OIL FILTERS - Install
new elements when necessary. Eefer to
Topic
11.
TRACKS - No lubrication necessary.
TRANSHISSION DRAIN PLUG - Drain, flush,
and refill every BOO hours of operation
with approved motor oil. Capacity 40
quarts.
TRANSMISSION CASE FILliE PLUG AND OIL
LEVEL BAYONNET GAUGE -Inspect
011
level
every' 10 hours of operation and keep the
oil level between "Low" and "Full" on
the bayonet gauge.
LUBEICATING OIL PRESSUEE GAUGE - Normal
operating pressure when engine is warm
at 'full throttle is 25 to 35 on the
gauge; if gauge does not register stop
engine immediately and determine the
cause.
BATTERIES - Keep the top and terminals
clean. Keep filled with clean distilled
water to 3/B" above separator plates;
inspect water level daily. Test with a
hydrometer.
AlE CLEANEf-S - Inspect and service every
10 hours of operation. Refer to Topic
13.
CRANKCASE FILLER CAP - One filler point.
Change oil every 30 to 60 hours of
operation. USE NON-CORROSIVE DIESEL
LUBRICATING OILS CONTAINING ADDITIVES
PHEVENTING SLUDGE OR GUM DEPOSITS. Cap-
acity 14 quarts.
SECOND STAGE FUEL OIL FILTEE - Install
new element when necessary, that is,
when pressure drops below normal range
(25 to 65) due to filter clogging. Re-
fer to Topic
11.
PRE-CLEANERS - Inspect and service ev-
ery 10 hours of operation. Refer to
Topic 12.
CRANKCASE DRAIN PLUG - One drain point.
Drain and refill with new oil every 30
to 60 hours of operation. Eefer to Topic
lAo
PRIMAEY OIL FlITER - Clean the Primary
Oil Filter at each crankcase oil change.
Eefer to Topic 10.
WATER PU},!PDEAIN - Periodically drain
and flush out system. Refer to Topic 18.
RADIATOR DRAIN - Periodically drain and
flush out system. Eefer to Topic lB.
Capacity 12 gallons.
22.
23.
24.
25.
26.
27.
28.
29.
30.
31.
