AGA FFD Manual de usuario

Cooking

Guide

included

inside

09/07 EINS 511612

PLEASE READ THESE INSTRUCTIONS BEFORE USING THIS APPLIANCE

REMEMBER, when replacing a part on this appliance, use only spare parts that

you can be assured conform to the safety and performance specification that we

require. Do not use reconditioned or copy parts that have not been clearly

authorised by Aga

For use in GB and IE

Comprising

Installation & Users

Instructions

Cooking

Guide

COMPANION (FFD)

(with Gas Hob)

OWNERS MANUAL

SECTION PAGE

INSTALLATION SECTION 3

INSTALLATION 4

TECHNICAL DATA 5

ELECTRICAL CONTROLS 6

LOCATION 7

PRODUCT DIMENSIONS 8

CONNECTING TO GAS 9

PRESSURE TESTING 10

USERS GUIDE 11

GENERAL INFORMATION 12

HEALTH & SAFETY 13

PRODUCT VIEW 14

CONTROL PANEL 15

GAS HOTPLATE 16

THE GRILL AND THE OVENS 17

OVEN COOKING GUIDE 18 - 22

CLEANING AND CARING FOR YOUR COOKER 23 - 25

SERVICING 26

WIRING DIAGRAM 27

CONTENTS

Installation

Section

INSTALLATION

WARNING: THIS APPLIANCE SHALL BE INSTALLED IN ACCORDANCE WITH THE

REGULATIONS IN FORCE AND ONLY USED IN A WELL VENTILATED SPACE. READ THE

INSTRUCTIONS BEFORE INSTALLING OR USING THIS APPLIANCE.

PRIOR TO INSTALLATION, ENSURE THAT THE LOCAL DISTRIBUTION CONDITIONS

(NATURE OF GAS AND GAS PRESSURE) AND THE ADJUSTMENTS OF THE APPLIANCE

ARE COMPATIBLE.

THE ADJUSTMENT CONDITIONS FOR THIS APPLIANCE ARE STATED ON THE DATA

PLATE WHICH IS SITUATED IN THE CENTRE VENT SLOT NEAR THE BASE OF THE

FRONT PLATE

This appliance is not connected to a combustion products evacuation device. It shall be installed

and connected in accordance with current installation regulations. Particular attention shall be

given to the relevant requirements regarding ventilation. (B.S. 5440 Part 2: 1989)..

It should be in accordance also with any relevant requirements of the Gas Region and Local

Authority.

In your own interest, and that of safety to comply with the law, all gas appliances must be

installed by a competent person. Failure to install appliances correctly could lead to prosecution.

On completion, test the gas installation for soundness.

WARNING: THIS APPLIANCE MUST BE EARTHED

The appliance is designed for the voltage stated on the data plate.

The Companion is supplied from the manufacturers in a fully assembled and tested condition.

HOTPLATE

NATURAL GAS G20 - (APPLIANCE CATEGORY I2H)

R.H.F. L.H.R. R.H.R. L.H.F.

BURNER TYPE ULTRA-RAPID RAPID SEMI-RAPID SEMI-RAPID

MAXIMUM HEAT 3.5 kW 3.0 kW 1.75 kW 1.75 kW

INPUT

INJECTOR MARKING 130 116 097 097

PRESSURE POINT POSITION:REAR LH SIDE OF APPLIANCE AT HOTPLATE LEVEL

PRESSURE SETTING: 20mbar

BURNER IGNITION: H.T. SPARK

PROPANE G31 - (APPLIANCE CATEGORY I3+)

R.H.F. L.H.R. R.H.R. L.H.F.

BURNER TYPE ULTRA-RAPID RAPID SEMI-RAPID SEMI-RAPID

MAXIMUM HEAT 3.5 kW 3.0 kW 1.75 kW 1.75 kW

INPUT (250g/h) (214g/h) (125g/h) (125g/h)

(0.50 l/h) (0.42 l/h) (0.25 l/h) (0.25 l/h)

INJECTOR MARKING 95 85 65 65

PRESSURE POINT POSITION:REAR LH SIDE OF APPLIANCE AT HOTPLATE LEVEL

PRESSURE SETTING: G30: 28-30 mbar G31 - 37 mbar

BURNER IGNITION: H.T. SPARK

ELECTRIC GRILL AND OVENS

GRILL ELEMENT - POWER RATING 2 x 0.95 kW

TOP OVEN - POWER RATING 1.4kW

LOWER OVEN (FANNED) - 1.75kW

TECHNICAL DATA

ELECTRICAL CONTROLS

Electrical connections are located at the back of the appliance

Refer to Figs. 1A for wiring connection to the appliance.

Remember that an excess of cable length is required for the possible withdrawal of the cooker.

Always double check connections and ensure terminals are fully tightened and the cable is

secured to the cable clamp.

THE ISOLATOR SHOULD NOT BE POSITIONED IMMEDIATELY ABOVE THE COMPANION

COOKER, BUT MUST BE SITED WITHIN 2 METRES OF THE APPLIANCE.

The Companion requires a 30 amp power supply fitted in conjunction with a double pole isolator

with a minimum contact clearance of 3mm and be connected to the mains with a minimum 4mm2

cable to comply with the latest editions of the local and national wiring regulations.

FIG. 1A

DESN 513370

DESN 513372

MINIMUM 4mm2AND MUST COMPLY WITH THE LATEST EDITIONS OF THE LOCAL

AND NATIONAL WIRING REGULATIONS

REMOVE COVER (4

SCREWS) TO GAIN ACCESS

TO THE MAINS TERMINAL

This is a CLASS1, type X appliance.

Any side wall above the hob on either side shall be greater than 60mm horizontally from the

cooker only when adjacent to combustible material (Fig. 2).

Surfaces over the top of the cooker must not be closer than 650mm.

The vent slots in the back of the top plate must not be obstructed.

INSTALLATION/LEVELLING

The Aga Companion is designed to stand on a flat and level surface, however, any unevenness

may be overcome by packing under the corners of the plinth with a suitable non combustible

material, (up to 2-3mm).

LOCATION

PRODUCT DIMENSIONS

Fig. .2 DESN 511616

60mm*

595mm

910mm

600mm

680mm

1080mm

948mm

APPLIANCE CAN BE CLOSE

FITTED TO KITCHEN UNITS UP

TO WORK TOP HEIGHT.

116mm

* WHEN ADJACENT TO COMBUSTIBLE MATERIAL

This cooker can be installed with an approved appliance flexible connection. Supply piping

should not be less than R 1/2 (1/2” BSP). Connection is made to the R 1/2 (1/2” BSP) female

threaded entry in the inlet block located just below the hotplate level on the rear left hand side of

the cooker.

Check for gas soundness after connecting the gas supply.

The gas bayonet connector must be fitted in the shaded area indicated in Fig. 3 . Take into

account that it must be possible to pull the cooker forward sufficiently. Ensure flexible hose is not

trapped between electrics cover and rear wall. Ensure hose is routed within shaded area, and

away from shielded oven vent.

The flexible hose must be in accordance with the relevant standards.

NOTE: FOR L.P.G. APPLIANCE

The flexible hose must be suitable for use with Propane gas, capable of 70°C temperature rise,

and carry a red stripe, band or label. If in doubt contact your supplier.

CONNECTING TO GAS

Fig. 3 DESN 511751

480

390

200

460

573

279

558

TERMINAL BLOCK

COVER

The pressure test point is situated at the rear left hand side of the appliance just below hotplate

level.

Remove screw from pressure test nipple. Fit the pressure gauge onto the pressure test nipple.

Place one of the burner heads and burner cap into position on the hotplate. Light this burner by

pushing in the appropriate control knob, and turning it anti-clockwise to the full on position.

For Natural Gas appliance, the pressure should be 20mbar (8 inches water gauge).

For LPG appliance the pressure should be Propane 37mbar and Butane 28-30mbar.

Turn off the tap, disconnect the pressure gauge and refit pressure test screw to pressure test

nipple.

Check for gas soundness.

PRESSURE TESTING

Otros manuales para FFD

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Quemador de AGA

AGA

AGA 7 Series Manual de instrucciones

AGA

AGA eR7 Series Manual de usuario

AGA

AGA LPRT 517725 Manual de instrucciones

AGA

AGA Masterchef II Ceramic Manual de usuario

AGA

AGA TC MODULE (FFD)(with Gas Hob) Manual de usuario

AGA

AGA DC3 Manual de instrucciones

AGA

AGA TC/DC Manual de uso y cuidado

AGA

AGA TC3 Manual de instrucciones

AGA

AGA Six Four Series Manual de usuario

AGA

AGA 4-oven Manual de usuario

AGA

AGA FFD Manual de usuario

AGA

AGA SIX-FOUR Series Manual de usuario

AGA

AGA AG1M251730 Manual de usuario

AGA

AGA Six Four Series Manual de usuario

AGA

AGA ELECTRIC HOB UNIT Manual de usuario

AGA

AGA CITY60 CONTEMPORARY Manual de usuario

AGA

AGA 60 Manual de instrucciones

AGA

AGA 60 Manual de usuario

AGA

AGA Companion Manual de usuario

Manuales populares de Quemador de otras marcas

Siemens

Siemens EX875KYV1E Hoja de especificaciones

AEG

AEG CERAMIC HOB 6010 K Manual de usuario

VALERA

VALERA CT 70A Manual de usuario

Zanussi

Zanussi ZGF 6420 Manual de usuario

Gaggenau

Gaggenau CI 273 Manual de usuario

G3 Ferrari

G3 Ferrari Energy Manual de usuario

Pkm

Pkm IN4B Manual de usuario

Award

Award H903BG Manual de usuario

Zanussi

Zanussi VCH 5005 RZ Manual de usuario

Miele

Miele KM 523 Manual de usuario

Hotpoint

Hotpoint IS67V8CCXT/E Manual de usuario

AEG

AEG HK854870XB Manual de usuario

Cookology

Cookology SEP600BK Manual de usuario

Bauknecht

Bauknecht Hob Manual de usuario

Zanussi

Zanussi ZGM 782 Manual de usuario

dipo INDUCTION

dipo INDUCTION DIBK218S Manual de usuario

Miele

Miele KM 5987 Manual de usuario

Miele

Miele KM 360 G Manual de usuario