Advantech CompactPCI MIC-3021/8 Manual de usuario

MIC-3021/8

6U/7U

CompactPCI ® Industrial

Computer for Rackmounting

All manuals and user guides at all-guides.com

all-guides.com

MIC-3021/8 User's Manual

Part No. 2003302100 1st Edition

Printed in Taiwan April 1999

This document is copyrighted, 1999. All rights are reserved. The

original manufacturer reserves the right to make improvements to the

products described in this manual at any time without notice.

No part of this manual may be reproduced, copied, translated or

transmitted in any form or by any means without the prior written

permission of the original manufacturer. Information provided in this

manual is intended to be accurate and reliable. However, the original

manufacturer assumes no responsibility for its use, nor for any

infringements upon the rights of third parties which may result from its

use.

Acknowledgements

PICMG, CompactPCI and the PICMG, CompactPCI logos are

trademarks of the PCI Industrial Computers Manufacturers Group

All other product names or trademarks are properties of their

respective owners.

All manuals and user guides at all-guides.com

Preface and Table of Contents

Product warranty

Advantech warrants to you, the original purchaser, that each of its

products will be free from defects in materials and workmanship for

one year from the date of purchase.

This warranty does not apply to any products which have been

repaired or altered by persons other than repair personnel authorized

by Advantech, or which have been subject to misuse, abuse, accident

or improper installation. Advantech assumes no liability under the

terms of this warranty as a consequence of such events.

Because of Advantechs high quality-control standards and rigorous

testing, most of our customers never need to use our repair service. If

an Advantech product is defective, it will be repaired or replaced at no

charge during the warranty period. For out-of-warranty repairs, you

will be billed according to the cost of replacement materials, service

time and freight. Please consult your dealer for more details.

If you think you have a defective product, follow these steps:

1. Collect all the information about the problem encountered. (For

example, CPU speed, Advantech products used, other hardware

and software used, etc.) Note anything abnormal and list any on-

screen messages you get when the problem occurs.

2. Call your dealer and describe the problem. Please have your

manual, product, and any helpful information readily available.

3. If your product is diagnosed as defective, obtain an RMA (return

merchandize authorization) number from your dealer. This allows us

to process your return more quickly.

4. Carefully pack the defective product, a fully-completed Repair and

Replacement Order Card and a photocopy proof of purchase date

(such as your sales receipt) in a shippable container. A product

returned without proof of the purchase date is not eligible for

warranty service.

5. Write the RMA number visibly on the outside of the package and

ship it prepaid to your dealer.

All manuals and user guides at all-guides.com

MIC-3021/8 User's Manual

Packing List

Before installing your board, ensure that the following materials have

been received:

 1 MIC-3021/8 Compact PCI enclosure with backplane

 1 box of accessories

 1 warranty certificate

 This user's manual

If any of these items are missing or damaged, contact your distributor

or sales representative immediately.

Technical Support and Sales Assistance

If you have any technical questions about the MIC-3021/8 or any

other Advantech products, please visit our support website at:

http://support.advantech.com.tw

For more information about Advantech's products and sales informa-

tion, please visit:

http://www.advantech.com

All manuals and user guides at all-guides.com

Preface and Table of Contents

Contents

Chapter 1: General Information ..................... 7

1.1 Introduction ...................................................................... 8

1.2 Features ............................................................................ 9

1.3 Specifications .................................................................... 9

1.4 Dimensions ..................................................................... 11

Chapter 2: Installation ...................................13

2.1 Initial inspection ............................................................. 1 4

2.2 The MIC-3021/8 Chassis ............................................. 1 5

2.3 Installation Procedures ................................................. 1 7

2.3.1 Card Installation and Removal ............................ 1 7

2.3.2 Before Operating the System .............................. 1 9

2.3.3 Installing Peripherals ............................................ 2 0

2.3.4 Replacing the Fan Tray and Air Filter ................ 2 2

All manuals and user guides at all-guides.com

MIC-3021/8 User's Manual

Figures

Figure 1-1: MIC-3021/8 dimensions .......................................... 11

Figure 2-1: Front view of MIC-3021/8 ...................................... 1 5

Figure 2-2: Rear view of MIC-3021/8 ....................................... 1 6

Figure 2-3: Installing a card into the chassis ........................... 1 8

Figure 2-4: Install a device on the top tray .............................. 2 0

Figure 2-5: Attaching the mounting brackets to a 5.25" device

.................................................................................... 2 1

Figure 2-6: Attaching mounting brackets to a half-height

device for mounting in device space next to the fan

tray module ............................................................... 2 2

All manuals and user guides at all-guides.com

all-guides.com

Chapter 1 General Information 7

General Information

CHAPTER

All manuals and user guides at all-guides.com

8MIC-3021/8 User's Manual

1.1 Introduction

The MIC-3021/8 is an 8-slot 6U/7U-sized CompactPCI enclosure for

rack or panel mounting. It has eight 6U card slots, and has a device

bay which can accommodate devices and peripherals such as floppy

disk drives and hard disk drives. Its rugged construction and flexible

modular design allows users to configure it to meet the requirements

of individual applications.

The MIC-3021/8 comes in two versions: 6U high without a fan tray or

7U high with a fan tray. The 1U high fan module provides forced air

cooling in the system. Two 88-CFM high-speed fans are mounted in a

hot-swappable tray directly underneath the card slots. The fan's

tachometer output enables the alarm module to monitor the speed of

the fans. Tachometer signals are transmitted to the system through a

6-pin connector on the fan backplane. A protective circuit has been

designed into the fan backplane to reduce electrical spikes and noise

while hot swapping. This design allows users to replace fans safely

without turning the system off. The 7U high design also provides an

additional space beneath the device bay to install a 5.25" device.

The device bay itself accommodates up to five 5.25" or 3.5" devices, or

three devices when an ATX power supply unit is installed. It accepts

standard HDDs and FDDs; there is no need for expensive special

devices. Devices can be removed through the device bay front without

the need for disassembling the enclosure, providing the shortest

MTTR for device replacement. A lockable door prevents unauthorized

access to the devices and to the power on/off switch.

All manuals and user guides at all-guides.com

Chapter 1 General Information 9

1.2 Features

 Eight 6U card slots

 Easy rackmount or panelmount installation

 Accepts an ATX power supply, or two CompactPCI plug-in power

modules (optional)

 Device bay accommodates up to 5 devices, secured by a lockable

door

 Front removable devices

 Hot-swappable fan tray

 Optional fault detection and alarm module

1.3 Specifications

1.3.1 General

Construction: Aluminum frame and galvanized sheet steel

Device bay: Accommodates up to five 5.25" or 3.5" devices (or three

devices when an ATX power supply is installed), front removable

 12-slot space (48 TE), incl. 7 CompactPCI slots and one system slot.

 "Hot swappable platform complies with PICMG 2.1 R 1.0 Hot Swap

Specification

Dimensions (W x H x D, mounting flanges not included):

7U: 440 x 311 x 254 mm (17.3" x 12.25" x 10")

6U: 440 x 267 x 254 mm (17.3" x 10.5" x 10")

Weight: 12 kg

Operating temperature: 0 ~ 50° C (32 ~ 122° F)

Storage temperature: -20° C ~ 70° C (-4 ~ 158° F)

Relative humidity: 10 ~ 95% @ 40° C, non-condensing

Operating altitude: 0 to 10,000 feet (3048 meters)

All manuals and user guides at all-guides.com

10 MIC-3021/8 User's Manual

Storage/transit altitude: 0 to 40,000 feet (12,190 meters)

Shock: 10 G (operating); 30 G (storage/transit)

Random vibration:1 Grms (operating)

1.3.2 Fan Tray Module

Air flow:Two 88-CFM fans, providing 176 CFM in total

Power Consumption: 0.37 A @ 12 V per fan, 0.74 A total

Rated fan speed: 2200 rpm

Life expectancy: 50,000 hours @ 25° C

1.3.3 ATX Power Supply

Input: 90 ~ 135 or 180 ~ 265 VAC @ 47 ~ 63 Hz, switchable

Output: +3.3 V @ 15 A, +5 V @ 26 A, +12 V @ 9 A, -12 V @ 0.8 A

Minumum load: +3.3 V @ 0.3 A, + 5V @ 2 A, +12 V @ 1 A

Max output: 250 W total, 170 W for 5 V and 3.3 V

MTBF: 50,000 hours @ 70% load

Safety: UL/CUL/CE

All manuals and user guides at all-guides.com

Otros manuales para CompactPCI MIC-3021/8

Tabla de contenidos

Otros manuales de PC industrial de Advantech

Advantech

Advantech PCIE-1840 Manual de usuario

Advantech

Advantech ARK-2250L Manual de usuario

Advantech

Advantech PCE-2032 Manual de instalación y operación

Advantech

Advantech EPC-R3710NO-XAA100 Manual de usuario

Advantech

Advantech iDAQ-934 Manual de usuario

Advantech

Advantech SKY-6200 Manual de instalación y operación

Advantech

Advantech EIS-S232 Manual de usuario

Advantech

Advantech UNO-1372GH Manual de usuario

Advantech

Advantech UNO-137 V2 Manual de instalación y operación

Advantech

Advantech EBPC-5250 Manual de usuario

Advantech

Advantech MIC-720AI Manual de usuario

Advantech

Advantech DLT-V6210 Manual de usuario

Advantech

Advantech IPC-100 Manual de instalación y operación

Advantech

Advantech UNO-2372G Manual de usuario

Advantech

Advantech UTC-310GP-ATB0E Manual de usuario

Advantech

Advantech POC-S176 Series Manual de usuario

Advantech

Advantech UNO-2484G Manual de usuario

Advantech

Advantech ARK-1123 Manual de instalación y operación

Advantech

Advantech WISE-2200-M Manual de usuario

Advantech

Advantech UNO-3483G Series Manual de usuario

Advantech

Advantech TPC-5212W-633AE Manual de usuario

Advantech

Advantech UNO-148 Manual de usuario

Advantech

Advantech CompactPCI MIC-3665A Manual de usuario

Advantech

Advantech EPD-230 Manual de usuario

Manuales populares de PC industrial de otras marcas

Chipsee

Chipsee PPC-A72-101 Manual de usuario

MSI

MSI MS-9A76 Manual de usuario

Stackrack

Stackrack THOR200 Manual de usuario

Moxa Technologies

Moxa Technologies DA-682C Series Manual de usuario

Nodka

Nodka eBOX-3000-ETC Manual de usuario

Siemens

Siemens SIMATIC IPC627E Manual de usuario

MSI

MSI MS-9A89 Manual de usuario

Artila

Artila Matrix-516 Manual de usuario

Siemens

Siemens SIMATIC Rack PC 840 V2 Manual de usuario

Beckhoff

Beckhoff CX9020 Manual de usuario

Dell

Dell Embedded Box PC 5000 Manual de usuario

IBASE Technology

IBASE Technology ASB200-918 Series Manual de usuario

Lenovo

Lenovo ThinkCentre M90q Manual del propietario

IXXAT

IXXAT Econ 100 Manual de usuario

Kontron

Kontron KBox A-151-TGL Manual de usuario

AXIOMTEK

AXIOMTEK ICO500-518 Series Manual de usuario

JLT

JLT 1214N Manual de usuario

Beckhoff

Beckhoff C6925 Manual de usuario