A.O. Smith FPS 75 Manual

I';:::;::

t;;.\i(

--- -- ~

' ,~ K

-r~~ :--' :::=::;-

( ;,,' tF

~~~.

0-'1

n ; q

~;;;;~~,

II : ~

r=~~~

~~~

Models

FPS40 and 50

Series226-227

FPSE40 and 50

Series 226E

FPD40 and 50

Series226-227

ruc Wc ~~D~w

Preparedby the

Technical

InformationDept.

Irving,Texas FPS75

Series230-233

WATER PRODUCTS

COMPANY

A DIVISION OF A.O. SMITH CORPORATION

Printed in the U.S.A. 596 4575 PartNo.TC-O34

FPS/FPSE/FPD TECHNICAL TRAINING AND SERVICE WORKBOOK

WORKBOOK INTRODUCTION

Technical Information

Irvino. Texas

@1995

A.D. Smith

Water Products Co.

FPS/FPSE/FPD TECHNICAL TRAINING AND SERVICE WORKBOOK

TABLE OF CONTENTS

SUBJECT PAGE

PAGE

SUBJECT

Service and Operation

Choosing the Best Water Heater

3FPS 40 & 50

Introduction

When to choose the FPS 3Sequence of Operation

4Wiring Diagram 22

When to choose the FPSE

When to choose the FPD 5TroubleshootingIndex 23

PartsList 40

Venting Installation

Interior clearances FPS, FPSE, FPD 6FPSE & FPD 40 -50

Exteriorclearances FPS, FPSE 7Sequence of Operation 42

8Wiring Diagram 43

Exterior clearances FPD

9TroubleshootingIndex 44

Condensation

PartsList 66

Sealing the vent

Horizontal Length Calc. FPS,FPSE 11 FPS 75

VerticalLength Calc. FPS, FPSE 12 Sequence of Operation 68

13 69

Horizontal Length Calc. FPD

Vertical Length Calc. FPD 14

Wiring Diagram

Troubleshooting 70

PartsList 94

Down Length Calc. FPD 15

Part Infom1ation 96

Air for Combustion

Service Checklist 97

Checking the draft 16

17 General Q & A 99

Additional Problems

Negative Pressure

Make-up Air 20

FPS/FPSE/FPDTECHNICALTRAININGAND SERVICEWORKBOOK

CHOOSING THE BEST WATER HEATER

Technical Information

Irving, Texas

@1995

A.D.Smith

Water Products Co.

FPS/FPSE/FPDTECHNICAL TRAINING AND SERVICE WORKBOOK

CHOOSING THE BEST WATER HEATER cant.

FPS/FPSE/FPD TECHNICAL TRAINING AND SERVICE WORKBOOK

CHOOSING THE BEST WATER HEATER cant.

FPS/FPSE/FPD TECHNICAL TRAINING AND SERVICE WORKBOOK

VENTING INSTALLATION

FPS/FPSE/FPD TECHNICAL TRAINING AND SERVICE WORKBOOK

VENTING INSTALLATION cant.

Exterior installation clearance requirements are crucial and must be met to ensure

compliance with all safety and code requirements. If all clearances cannot be

met, do not unpack the heater.

Exterior

Clearances:

FPS

FPSE All exterior clearance requirements for the FPS and FPSE are measured from the

vent termination.

Min. clearances for side wall venting: Min. clearances for vertical:

Inside corner - 3' l' above or 4' to the side of any

Side of door or window - 4' gable, dormer, or roof structure

Above door or window - l' with building interior access.

Below a window - 4' l' above snow level.

Above public walkway - 7'

Above ground or snow level -1'

Air intake to a living space - 3' above if air intake is within 10'

FPS/FPSE/FPD TECHNICAL TRAINING AND SERVICE WORKBOOK

VENTING INSTALLATION cant.

Exterior installation clearance requirements are crucial and must be met to ensure

compliance with all safety and code requirements. If all clearances cannot be

met, do not unpack the heater.

Exterior

Clearances:

FPD

All exterior clearance requirements for the FPO are measured from the vent

termination.

Min. clearances for side wall venting: Min. clearances for vertical:

Inside corner - 3' l' above or 4' to the side of any

Side of door or window - 9" gable, dormer, roof structure

Above door of window - 9" with building interior access.

Above public walkway - 7' l' above snow level.

Above ground or snow level -1'

Air intake to a living space - 3' above if air intake is within 10'

@1995

A.D. Smith

Water ProductsCo. Technical Information

IrvinQ.Texas

FPS/FPSE/FPD TECHNICAL TRAINING AND SERVICE WORKBOOK

VENTING INSTAllATION cant.

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Calentador de agua de A.O. Smith

A.O. Smith

A.O. Smith CYCLONE Xi BTH 500A Manual de usuario

A.O. Smith

A.O. Smith DRE 52 Manual de usuario

A.O. Smith

A.O. Smith ProMax+plus High Efficiency SERIES 100 Manual de usuario

A.O. Smith

A.O. Smith CEWH-A1 Series Manual de servicio

A.O. Smith

A.O. Smith 101 Series Manual de usuario

A.O. Smith

A.O. Smith Fit it & Forget it HSE-SBS-006 Manual de usuario

A.O. Smith

A.O. Smith LTE 66D Manual de usuario

A.O. Smith

A.O. Smith ADMR-40 Guía de solución de problemas

A.O. Smith

A.O. Smith Commercial gas water heaters Manual de usuario

A.O. Smith

A.O. Smith FVIR Hoja de información del producto

A.O. Smith

A.O. Smith Burkay HW-300 Guía de aplicación

A.O. Smith

A.O. Smith ProMax Power-Vent 185237-004 Manual de usuario

A.O. Smith

A.O. Smith IT - 1000 Manual de usuario

A.O. Smith

A.O. Smith ELJH-30 Manual de usuario

A.O. Smith

A.O. Smith HSE-SBS 6 Manual de usuario

A.O. Smith

A.O. Smith Burkay HW-300 Guía de aplicación

A.O. Smith

A.O. Smith TE-35 Manual de usuario

A.O. Smith

A.O. Smith Series 100/101 Manual de usuario

A.O. Smith

A.O. Smith Water Heater 520 Direct Vent Indoor Manual de usuario

A.O. Smith

A.O. Smith SGS-28 Guía de solución de problemas

A.O. Smith

A.O. Smith Master-Fit BTR-151 through BTR-201 Manual de usuario

A.O. Smith

A.O. Smith Burkay HW-300 Manual del propietario

A.O. Smith

A.O. Smith Power Direct ventedGasModels Manual de usuario

A.O. Smith

A.O. Smith Saudi Arabia Manual de usuario

Manuales populares de Calentador de agua de otras marcas

Kenmore

Kenmore 153.582400 Manual de usuario

Applimo

Applimo Edel AIR Manual de usuario

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Manual de usuario

clage

clage E-Mini Series Manual de usuario

Toyotomi

Toyotomi Oil Miser OM-180 Manual de usuario

Bradford White

Bradford White EF Series Manual de usuario

Eccotemp

Eccotemp 40-H Manual de usuario

Dimplex

Dimplex ECSd125-580 Guía

Dux

Dux 32FCR6N Manual de usuario

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Guía de solución de problemas

Noritz

Noritz N-132M Manual de instrucciones

TESY

TESY GCV7/4S 10047 Hoja de especificaciones

Koryo

Koryo KWHZF15Y Manual de usuario

Pentair

Pentair PSC-14-4-02 Manual de usuario

GE 40M06AAG Instrucciones de montaje

Thermor

Thermor AEROMAX SPLIT 2 Manual de usuario

American Hometec

American Hometec AHQ-B03X Manual de usuario

PVI

PVI MAXIM Manual de usuario